- Batteries, Brushes, and Chargers

#PartDescription ReqNotesAvailability
1 162-0002 12V 185Ah wet battery (SNSR) 3
3 162-5062 36V 20amp battery charger with small SB50 gray plug 1 (configured for wet batteries; can be changed to support AGM batteries)
5 996-0120 13 inch medium grit scrubbing brush - 180 grit 2
6 996-0096 13 inch lite grit scrubbing brush - 500 grit 2

- Frequently Replaced Parts

#PartDescription ReqNotesAvailability
1 162-0002 12V 185Ah wet battery (SNSR) (3)
2 162-0047 12V 215Ah AGM battery (Group J185) (SNSR) (3)
3 162-5062 36V 20amp battery charger with small SB50 gray plug
162-9024 36V 12amp battery charger with small SB50 gray plug
5 991-2105 SB50 50amp charger plug with pins (gray)
6 998-0010 Battery jumper cable - ring type (red)
10 991-0101 Chain (sold by the link) (66)
11 991-0103 Master link
13 164-0041 Squeegee blade 32 inch linatex kit (red) (front and rear)
16a 164-0089 Squeegee vacuum hose with cuffs
17 164-9109 Gasket material 1/2 x 1 x 1 (sold by the foot) (7 ft)
18a 164-0043 Drain plug (OEM)
18b 991-5113 Drain plug (NON-OEM)
19 991-1212 36V 3 stage vacuum motor peripheral
20 991-1221 Carbon brush without plastic cover (pkg of 2) (for Lamb# 116)
21 991-1222 Plastic covered carbon brush (sold individually) (for Lamb# 119)
22 996-0169 13 inch heavy grit stripping brush - 80 grit
23 996-0120 13 inch medium grit scrubbing brush - 180 grit
27 996-0339 Drive lugs - metal (6)

- Pad Holders

#PartDescription ReqNotesAvailability
1 991-2214 Center-Lok II pad holder - left hand thread (red)
2a 991-2201 Center-Lok II pad holder - right hand thread (black) (Pad driver side female, Floor side male)
2b 991-8577 Pad retainer (Pad driver side male, Floor side female)
3a 991-2202 Big mouth pad holder set (blue) (includes 3 screws)
3b 991-2205 Deep lock ring and pad grip ring
6 996-0372 Big mouth pad holder (left hand thread)
7 N/A Not available
8 991-2209 Split retainer - pad holder ring (OBSOLETE)
10 991-2211 Center lock pad holding cup (male) (yellow) (OBSOLETE)

- Pads

#PartDescription ReqNotesAvailability
02 255-1435 14 inch Armadillo concrete scrubbing pad (pkg of 5)
03 255-1464 14 inch Blue ace pad (pkg of 5)
06 255-1477 14 inch Diamondback extreme stripping pad (pkg of 5)
10 255-1465 14 inch Heat concrete bonding pad (pkg of 5)
12 255-1487 14 inch Melamine Mela-Kleen pad (pkg of 2)        
13 255-1490 14 inch premium black stripping pad (pkg of 5)
14 255-1470 14 inch premium blue cleaning pad (pkg of 5)
15 255-1492 14 inch premium brown stripping pad (pkg of 5)
16 255-1480 14 inch premium green scrubbing pad (pkg of 5)
17 255-1460 14 inch premium red scrubbing pad (pkg of 5)
20 255-1411 14 inch superspeed rubberized pad (pkg of 5)
21 255-1495 14 inch razorback stripping pad (pkg of 5)
22 255-1447 14 inch Redwood maroon floor prep pad (pkg of 10)
25 255-0120 14 inch Professional sand screen 100 grit (pkg of 10)
26 255-0121 14 inch Professional sand screen 120 grit (pkg of 10)
30 255-0206 14 inch Superscreen sand screen 120 grit (pkg of 10)
32 255-0204 14 inch Superscreen sand screen 60 grit (pkg of 10)
33 255-1424 14 x 20 inch Tiger carpet bonnet (pkg of 2)
36 255-9543 14 inch Diamond by Gorilla 200 Grit (pkg of 2)
38 255-9544 14 inch Diamond by Gorilla 400 Grit (pkg of 2)
39 255-9545 14 inch Diamond by Gorilla 800 Grit (pkg of 2)
42 255-1482 14 inch Turbostrip segmented rotary pad (pkg of 4)
43 255-1415 14 inch Duala clean and shine pad - low speed (pkg of 5)

Back Panel and Levers

#PartDescription ReqNotesAvailability
401 164-0598 Brush lift handle (FSO) (OBSOLETE) 1
402 164-0572 Handle grip (FSO) (OBSOLETE) 2
404 N/A Not available 1 (not available) Hose clip
405 999-0545 Screw 10-24 x 1/2 pan head phillips self-tapping 4
408 999-0745 Screw 10-24 x 1 1/4 socket head shoulder 1
411 999-0202 Nut 1/2-13 hex plain finish 1
414 999-0152 Nut 1/4-20 nylon insert lock zinc plated 2
415b 164-0579 Lift block 1
416 999-0032 Washer 3/8 USS flat plain finish 1
417 999-0170 Nut 3/8-16 hex plain finish 1
419 164-0605 Squeegee lift rod threaded 1
420 164-0136 Bushing 1
421b 999-0198 Screw 1/4-20 x 1 1/4 socket cap alloy plain finish 1
422a 991-1223 36V solenoid contactor with 4 post 2 (4 post) Top solenoid is for the brushes. 2nd from the top is for master switch
422b 164-0583 Silicon rectifier (diode) 2
423a 164-0581 Solenoid 2 (6 post) 3rd solenoid from top is reverse. The bottom one is forward.
425 999-0060 Washer 1/4 split lock plain finish 4
427 999-0135 Screw 1/4-20 x 3/8 truss head slotted zinc 10
428 999-0060 Washer 1/4 split lock plain finish 10
429 164-0583 Silicon rectifier (diode) 4
432 999-0006 Washer 3/16 flat zinc plated 4
435 N/A Not available 1 (not available) Clevis pin
439 999-0200 Bolt 1/2-13 x 1 1/4 hex head 1
441 164-0130 Bushing 1
442 164-0130 Bushing 1
444 999-0200 Bolt 1/2-13 x 1 1/4 hex head 1
446 164-0572 Handle grip (FSO) (OBSOLETE) 1
447b N/A Not available 1 (not available) Speed control
447c 164-1092 Potentiometer for Dart speed control 1
449 N/A Not available 2 (not available) Angle support
451 N/A Not available 1 (not available) Brush lift shaft
453 164-0598 Brush lift handle (FSO) (OBSOLETE) 1
454 164-0497 Hair spring cotter pin (FSO) (OBSOLETE) 1
457 N/A Not available 1 (not available) Brush lift rod
459 999-0170 Nut 3/8-16 hex plain finish 1
462 999-0190 Nut 1/4-20 hex plain finish 1
463 999-0032 Washer 3/8 USS flat plain finish 1
464 999-0038 Bolt 3/8-16 x 1 hex head grade 5 zinc plated 1

Body, Squeegee, Skirts, and Battery

#PartDescription ReqNotesAvailability
102 N/A Not available 1 (not available) Switch panel
103 999-0035 Washer 3/8 x 1 1/2 fender 7
104 999-0013 Screw 10 x 5/8 pan head phillips sheet metal 6
105 999-0024 Washer 5/16 flat stainless steel 9
106 999-0132 Bolt 5/16-18 x 3/4 hex head grade 5 zinc plated 3
107 N/A Not available 1 (not available) Chassis housing
108 999-0019 Bolt 1/4-20 x 5/8 hex head grade 5 zinc plated 2
109 999-0016 Washer 1/4 flat plain finish 10
112 999-0060 Washer 1/4 split lock plain finish 8
115b 164-1086 70amp circuit breaker assembly 1
116 N/A Not available 1 (not available) Right skirt assembly
117 N/A Not available 1 (not available) Squeegee lift bracket
119a 164-0043 Drain plug 1 (OEM)
121 999-0123 Washer 1/4 SAE flat zinc plated 4
122 164-0428 Screw 1/4-20 x 1 7/8 hex head cap 2
123 164-1565 Knob 2
124 999-0069 Nut 5/16-18 hex 6
125 999-0105 Washer 5/16 external star lock zinc plated 4
126 164-0041 Squeegee blade 32 inch linatex kit (red) (front and rear) 1
127 164-0250 Inner channel for Wrangler 26 and 2625 1
128 999-0178 Bolt 5/16-18 x 2 hex head grade 5 zinc plated 2
135 999-0131 Screw 5/16-18 x 1 1/2 socket head stainless steel 2
136 999-0641 Screw 5/16-18 x 3/4 socket head stainless steel 2
137 164-0433 Squeegee housing (OBSOLETE) 1
138 991-2009 3 inch bumper wheel 2
140 999-0028 Washer 5/16 split lock plain finish 2
141 999-0029 Bolt 5/16-18 x 1/2 hex head plain finish 2
151 164-0480 Pivot arm assembly with bearing (OBSOLETE) 2
152 164-0439 Ball joint 2
155 999-0262 Nut 1/2-13 nylon insert jam lock zinc plated 4
157 999-0187 Washer 1/2 flat plain finish 4
158 N/A Not available 4 (not available) Latch
159 164-0445 Split key ring 4
160 N/A Not available 2 (not available) Rear skirt pin
161 164-0106 Retaining ring 6
162 991-5116 Side wiper urethane 2
164 N/A Not available 2 (not available) Splash guard
166a 164-0451 Right skirt only (FSO) (OBSOLETE) 1
166b N/A Not available 1 (Left skirt only)
168 999-0136 Bolt 1/4-20 x 1 1/4 hex head grade 5 zinc plated 2
170 N/A Not available 6 ft Front body stripe (FSO)
171 999-0185 Screw 3/8-16 x 3/4 flat head slotted zinc plated 4
174 N/A Not available 2 (not available) Bumper roller
175 164-0457 Bumper roller bracket (FSO) (OBSOLETE) 2
177 NOTE Please See Batteries, Brushes, Pad Holders and Charger Pages
178 164-0460 Battery block (FSO) (OBSOLETE) 1
179 164-0461 Squeegee roller bracket (OBSOLETE) 2
180a 998-0010 Battery jumper cable - ring type (red) 2 (For use with top, bolt type post batteries)
180b 991-6025 Wire 4 x14.5, 3/8 ring x 3/8 ring 2 (NON-OEM)
182 N/A Not available 1 (Left brush motor shield)
184 N/A Not available 1 Battery tray assembly
186 991-1405 Vinyl tubing 1/2 x 3/4 (sold by the inch) 18 in
187 164-0398 Control valve (white clamp) 1
189 164-0287 Rubber switch boot 1
191 N/A Not available 1 (not available) Wire from forward solenoid to brush motor

Brush Motor

#PartDescription ReqNotesAvailability
600 N/A Not available 1 Brush drive motor
601 999-0175 Screw 1/4-20 x 3/8 pan head slotted zinc plated 3
602 164-0637 Top cover (OBSOLETE) 1
603 164-0638 Top end bell with brush board assembly (OBSOLETE) 1
604 N/A Not available 1 Heyco strain relief
605 164-0323 Lead assembly (1 wire with terminals) 2 1 wire with terminals
607 999-0174 Screw 10-32 x 3/8 pan head slotted brass 4
609 999-0545 Screw 10-24 x 1/2 pan head phillips self-tapping 3
611 N/A Not available 1 Stator frame assembly with magnets
612 164-0328 Washer 1 7/8 wave 1
613 164-0329 Top rotor bearing 1 Commutator end
615 164-0132 Square keyway 1/4 x 1/4 1
616 164-0332 Bearing (shaft end) 1
617 164-0650 Bottom end bell (OBSOLETE) 1
618 164-0651 Thru bolt (OBSOLETE) 2
619 164-0335 Shaft seal 1

Control Panel and Solution Lever

#PartDescription ReqNotesAvailability
501 164-0608 Handle grip (FSO) (OBSOLETE) 2
504 N/A Not available 1 Operating label (FSO)
505 999-0113 Screw 1/4-20 x 1/2 truss head slotted 2
508 999-0190 Nut 1/4-20 hex plain finish 2
511a 164-0565 90 degree brass elbow 1
511b 164-0566 Brass hose barb 1/4 NPT x 1/2 inch (OBSOLETE) 1
513a 164-1077 60amp circuit breaker (OBSOLETE) 1
514 164-0617 90 degree hose barb 1
515 164-0023 Toggle switch 1 (brush)
518 999-0019 Bolt 1/4-20 x 5/8 hex head grade 5 zinc plated 2
519 164-0619 Valve lever 1
522 999-0020 Bolt 1/4-20 x 3/4 hex head grade 5 zinc plated 1
523 999-0016 Washer 1/4 flat plain finish 1
528 991-1401 Clear vinyl tubing (sold by the inch) 21 in to right brush
530 999-0152 Nut 1/4-20 nylon insert lock zinc plated 4
531 N/A Not available 1 Valve link (FSO)
532 N/A Not available 1 Valve arm (FSO)
540 999-0102 Screw 6-32 x 1 round head slotted zinc plated 2
542 164-0631 Valve handle grip (FSO) (OBSOLETE) 1
545 999-0061 Screw 1/4-20 x 5/16 cup point socket set alloy plain finish 4
546a 999-0107 Bolt 3/8-16 x 2 hex head grade 5 zinc plated 1
549 164-0026 Snap switch 1
550 N/A Not available 2 Switch handle (FSO)
551 N/A Not available 2 Flange bearing (FSO)
552 999-0060 Washer 1/4 split lock plain finish 1
554 164-2000 Forward/reverse switch (6 prong) 1
556a 164-1087 Knob with set screw 1
556b 172-2039 5K potentiometer 1

Drive Motor

#PartDescription ReqNotesAvailability
628 N/A Not available 1 (Heyco strain relief)
629 164-0323 Lead assembly (1 wire with terminals) 2
631 999-0174 Screw 10-32 x 3/8 pan head slotted brass 4
634 164-0326 Brush ring assembly with springs and carbon brush 1
635 164-0327 Stator frame assembly with magnets 1
639 164-0132 Square keyway 1/4 x 1/4 1
640 164-0332 Bearing (shaft end) 1
642 N/A Not available 2 (Thru bolt)
643 164-0335 Shaft seal 1
644a 164-0172 36V drive motor 1 (includes 625-643) (OEM)
644b 991-5114 36V drive motor 1 (includes 625-643) (NON-OEM)

Frame and Undercarriage

#PartDescription ReqNotesAvailability
201 N/A Not available 1 Base plate
204a 991-2006 Caster wheel assembly (red) 2
204b 991-2008 4 inch caster wheel with bearings (red) 2
207 N/A Not available 2 (not available) Lift arm
208 164-0130 Bushing 1
210 N/A Not available 1 (not available) 10 inch drive wheel
211 N/A Not available 2 (not available) Brush drive motor
212 164-0132 Square keyway 1/4 x 1/4 2
213 N/A Not available 1 Motor plate
214 164-0524 Brush pressure washer (FSO) 1
215 999-0132 Bolt 5/16-18 x 3/4 hex head grade 5 zinc plated 2
216 999-0105 Washer 5/16 external star lock zinc plated 2
217 999-0024 Washer 5/16 flat stainless steel 2
218 999-0113 Screw 1/4-20 x 1/2 truss head slotted 2
219 999-0034 Washer 3/8 split lock plain finish 2
220 164-0136 Bushing 2
221 164-0135 Latch 2
222b 164-0493 Right brush drive assembly 1
225 164-0496 Clevis (FSO) (OBSOLETE) 1
226 164-0497 Hair spring cotter pin (FSO) (OBSOLETE) 1
228 164-0499 Brush pressure spring (FSO) (OBSOLETE) 1
230 999-0188 Nut 3/8-16 nylon insert lock zinc plated 4
233c 991-2209 Split retainer - pad holder ring (OBSOLETE) 2
233d 991-2211 Center lock pad holding cup (male) (yellow) (OBSOLETE) 2 Center Lock
233h 164-0510 Mounting screws (pad holder base) 1 Package of 3
233i 996-0675 Medium grit scrubbing brush - 180 grit 2 Wrangler 27
233j 996-0339 Drive lugs - metal 6
233l 991-2214 Center-Lok II pad holder - left hand thread (red) 2 (NON-OEM)
235 999-0016 Washer 1/4 flat plain finish 4
236 999-0297 Bolt 1/4-20 x 1 hex head stainless steel 4
238 999-0424 Bolt 5/16-18 x 1 hex head stainless steel 6
239 991-0103 Master link 1
240 164-0332 Bearing (shaft end) 2
241 164-0513 Wheel sprocket 1
243 164-0515 Motor sprocket includes set screws 1 Includes screws
245 164-0132 Square keyway 1/4 x 1/4 1
246a 164-0172 36V drive motor 1 (OEM)
246b 991-5114 36V drive motor 1 (NON-OEM)
247 999-0157 Screw 5/16-18 x 3/8 cup point socket set alloy plain finish 1
251 164-0519 Flanged bearing 8
253 164-0130 Bushing 8
254 164-0519 Flanged bearing 2

Lid, Front Cover and Tanks

#PartDescription ReqNotesAvailability
301 N/A Not available 1 (not available) Vacuum Cover Label
302 N/A Not available 1 (not available) Top cover
303 164-9109 Gasket material 1/2 x 1 x 1 (sold by the foot) 7 ft
304 999-0103 Screw 1/4-20 x 3/4 truss head slotted zinc 4
306 N/A Not available 1 (not available) Recovery tank
307 164-0073 Gasket sponge 1/2 x 1 (sold by the foot) (OBSOLETE) 8 ft
308 999-0662 Screw 1/4-20 x 2 round head phillips zinc plated 8
310 164-0532 Drain tube gasket (OBSOLETE) 2
311 N/A Not available 2 (not available) Drain tube gasket
312 164-0534 Washer (FSO) 2
313 999-0060 Washer 1/4 split lock plain finish 8
314 999-0190 Nut 1/4-20 hex plain finish 8
317b 991-8568 Squeegee vacuum hose 1 (NON-OEM)
317c 991-8568 Squeegee vacuum hose 1 (NON-OEM)
318 N/A Not available 1 (not available) Drain hose assembly
319 164-0569 Plug strap (FSO) (OBSOLETE) 1
322 164-0566 Brass hose barb 1/4 NPT x 1/2 inch (OBSOLETE) 1
324 N/A Not available 1 Clean water label (FSO)
325 N/A Not available 1 Battery & charger label (FSO)
328 N/A Not available 1 (not available) Vacuum chamber plate
329 999-0071 Screw 10-24 x 1/2 flat head slotted zinc plated 6
330 164-0565 90 degree brass elbow 1
331 999-0297 Bolt 1/4-20 x 1 hex head stainless steel 2
332 164-0564 Solution drain plug 1
334 164-0545 Float chamber (FSO) (OBSOLETE) 1
335 N/A Not available 1 Warning label (FSO)
336 999-0569 Screw 10 x 1/2 pan head phillips sheet metal 8
337 164-0547 Hood cover gasket (FSO) (OBSOLETE) 1
338 N/A Not available 1 (not available) Air duct
339 N/A Not available 1 side skirt mount bracket
340 N/A Not available 1 (not available) Air plate
341 N/A Not available 1 (not available) Gasket
342 999-0663 Screw 10-24 x 3/8 pan head phillips thread cutting 4
343 N/A Not available 1 (not available) Mount plate
346 991-1212 36V 3 stage vacuum motor peripheral 1
347 164-0807 Vacuum exhaust gasket 1
348a 274-0768 FILTER-DOME 1 (OEM)
348c 164-0549 Vacuum filter with extruded gasket (OBSOLETE) 1 gasket on top of filter
349 N/A Not available 1 (not available) Solution drain hose
350 997-2005 Hose clamp 1
351 N/A Not available 1 (Solution pipe)
355 999-0102 Screw 6-32 x 1 round head slotted zinc plated 2
356b 991-2105 SB50 50amp charger plug with pins (gray) 1
359 164-0558 1 90 degree vinyl hose barb 1
361 N/A Not available (not available) 2 inch hose

Wiring

#PartDescription ReqNotesAvailability
001a 998-0010 Battery jumper cable - ring type (red) (For use with top, bolt type post batteries)
001b 991-6025 Wire 4 x14.5, 3/8 ring x 3/8 ring (NON-OEM)
003 164-0671 Circuit breaker lead
006 164-0672 Positive lead (OBSOLETE)
035 N/A Not available Wire from drive motor to forward solenoid (FSO)
036 164-0473 Positive battery cable to forward solenoid (FSO) (OBSOLETE)
040 N/A Not available Wire from vacuum motor to switch (FSO)
041 N/A Not available Wire from brush solenoid to brush switch
042 164-0680 Wire from forward solenoid to speed control (FSO) (OBSOLETE) (to positive battery on speed control)
045 N/A Not available Wire from reverse solenoid to resister (FSO)
046 N/A Not available Wire from reverse solenoid to speed control (FSO)
050 N/A Not available Wire from brush solenoid to light (FSO)
052 N/A Not available Wire from reverse solenoid to forward solenoid (FSO)
055 N/A Not available Wire from reverse solenoid to forward/reverse switch (FSO)
057 N/A Not available Wire from brush solenoid to brush switch
058 N/A Not available Wire from master solenoid to master switch (FSO)
060 164-0698 Vacuum switch jumper wire (FSO) (OBSOLETE)
061d N/A Not available (not available) Wire from charger plug to battery
062 164-0700 Wire from vacuum switch to brush switch
066 164-0704 Wire from reverse solenoid to deadman switch (OBSOLETE)