- Commonly Asked For Parts

#PartDescription ReqNotesAvailability
01 272-7380 Engine kit - DC retro for dust control (OBSOLETE) Dust Control models - FH500V/FH541V No longer available.
02 272-7381 Engine retro kit with catalytic converter Catalytic control models - FH500V/FH541V No longer available.
03 272-6584 Dust bonnet For FS481V engine
04 162-0006 12V 18Ah AGM battery (size 6) 1
05 N/A Not available (Propane adapter)

- Engine - Kawasaki FS481V

#PartDescription ReqNotesAvailability
001 178-0329 Bolt 12 x 30 1
002 178-0135 Washer 1 (DS10 only)
003 178-0137 Woodruff key 1
004 178-7107 Flywheel assembly 1
005 189-5152 Propane emission decal 1
006 189-0392 Screw #10 x 5/8 pan head phillips 2
007a 189-8544 Emissions shutdown module with oxygen sensor 1 (Betco)
007b 154-1042 SafeSense emission monitoring module retro kit 1 (Pioneer)
008a 189-3090 Oil dipstick 1 (Plastic oil dipsticks are only good for a short time because the last couple inches of the dipstick are always in oil and will eventually stain, get brittle, and then break off inside the engine due to the high heat of the oil. The pieces of plastic can cause problems inside the engine and the only way to get them out is to remove the crankcase, which is very labor intensive.)
008b 154-0367 Kawasaki dipstick 1
009a 178-0306 Dipstick tube 1
009b 178-0016 O-ring 2
010 178-0265 Voltage regulator 1
011 178-0330 Wire lead 1
012 178-0331 Screw 2
013 178-0123 Flanged bolt 4
014 178-7106 Electric starter 1
015a 178-0264 Ignition coil assembly Kawasaki FS481V 2
015b 991-7143 Ignition coil assembly 2 (NON-OEM)
016a 166-0008 Spark plug (Kawasaki FS481V) 2
016b 178-7104 Spark plug wiring harness 1
017 178-0280 Intake manifold 1
018a 178-0255 Air pre-filter 1 (OEM)
018b 991-6028 Air pre-filter 1 (NON-OEM)
019a 178-0256 Air filter 1 (Betco) (OEM)
019b 991-6029 Air filter 1 (NON-OEM)
019c 178-0256 Air filter 1 (Kawasaki)
019d 178-7207 Air filter assembly with prefilter 1 (Kawasaki)
020 178-0281 Hose clamp 1
021 178-0282 Hose 1
022 178-0279 Air filter case 1
023 178-0278 O-ring 2
024 178-0277 Thumb nut 2
025 178-0283 Hose clamp 1
026a 178-0290 Carburetor assembly 1 (Pioneer, Nilfisk, Kawasaki)
026b 189-5148 Carburetor aluminum block (keep internal parts of old carb) 1 (Betco)
027 178-0284 Stud bolt 2
028 178-0332 Plug 1
029 178-0333 Clamp 1
030 178-0195 Flanged nut 2
031 178-0334 Intake pipe 1
032 178-0042 Carb intake gasket 2
033 178-0257 Gasket 2
034 178-0036 Exhaust stud bolt 4
035 178-0335 Bolt 6 x 12 7
036 178-7108 Breather cover 1
037 178-0263 Breather gasket 1
038 189-8452 J clip stamped hook 1
039 178-7109 Breather pipe 1
040 178-0151 Screw pan head 1
041 178-7110 Breather plate 1
042 178-7111 Breather valve 1
043 178-0043 Top oil seal (upper crankshaft - Kawasaki) 1
044a 178-0113 Plug 1
044b 178-0010 Oil drain adapter 1
044c 178-0016 O-ring 2
045a 178-0254 Oil filter 1 (OEM)
045b 991-6027 Oil filter 1 (NON-OEM)
046 154-0143 Oil pressure switch with 2 prongs 1
047 178-0206 Clamp 1
048 178-7012 Plug 1
049 178-0336 Crankcase complete 1 (includes 50)
050 178-0337 Joint 1
051 178-0302 O-ring 1
052 178-0338 Pipe 3
053 178-0273 Dowell pin 6
054 178-0261 Cylinder head gasket (FS481V engine only) 2
055a 178-0304 #1 right cylinder head assembly (FS481V) 1 (Includes (1) rocker cover gasket, (2) valve springs, (1) intake valve, (1) exhaust valve, (1) cylinder head gasket, (1) intake gasket, (1) exhaust gasket, (2) exhaust studs)
055b 178-0258 Right (while operating) bare cylinder head #1 1
055c 178-0305 #2 left cylinder head assembly (FS481V) 1 (Includes (1) rocker cover gasket, (2) valve springs, (1) intake valve, (1) exhaust valve, (1) cylinder head gasket, (1) intake gasket, (1) exhaust gasket, (2) exhaust studs)
055d 178-0259 Left (while operating) bare cylinder head #2 1
056 178-0272 Head bolt 14
058 178-0339 Lift hook 1
059 178-0032 Valve stem seal 4
060 178-0124 Bolt 6 x 25 flange 10
061a 178-7112 Rocker case (cylinder #2) 1
061b 178-7113 Rocker case (cylinder #1) 1
062 178-0262 Rocker case gasket 2
064 178-0272 Head bolt 14
065 178-0036 Exhaust stud bolt 4
066 178-0271 Head bolt 6
067 999-1489 Screw 3/8-16 x 1 1/2 hex head stainless steel 4
068 999-0034 Washer 3/8 split lock plain finish 4
069 178-0260 Bottom oil seal 1
071 178-0236 Plug 2
073 178-0340 Plug 1
074 178-0084 Oil seal 1
075 178-0322 Crankcase cover 1
076 178-0338 Pipe 3
077 178-0273 Dowell pin 6
078 204-0071 Bolt 1
079 999-0120 Washer 3/8 SAE flat 1
080 189-8544 Emissions shutdown module with oxygen sensor 1 (Betco)
081 189-5147 Nut 1
082a 169-0142 Muffler plug 1 (Pioneer)
082b 991-1601 Oxygen sensor 1 wire (OBSOLETE) 1
083a 189-3087 Catalytic muffler and manifold assembly 1 (Betco)
083b 154-1044 Catalytic muffler and manifold assembly (Kawasaki FS481V) 1 (Pioneer)
084 178-0286 Fan housing kit 1
090 178-7133 Bolt 4
091 178-0386 Washer 4
092 178-0098 Collet (valve keeper) (sold individually - need 2 per valve) 8
093 178-0048 Valve retainer ring 4
094 178-0276 Valve spring 4
095 178-0270 Intake valve 2
096 178-0045 Lifter 4
097 178-0268 Push rod 4
098 178-0269 Exhaust valve 2
099 178-7134 Nut 4
100 178-0353 Bracket 4
101 178-0384 Bolt 8 x 14 flange 4
102 178-7132 Collar 4
103 178-0383 Rocker arm 4
KIT 050-0007 Kawasaki FS481V 100 hour kit 1 (includes oil filter, pre-air filter, air filter and spark plug)
N/S 189-8544 Emissions shutdown module with oxygen sensor 1
N/S 991-1810 Compression tester 1
N/S 991-1832 Emission tester 1
N/S 178-0402 Throttle control plate 1
N/S 178-0313 Charging coil (stator) 1
N/S 178-0275 Spring 1
N/S 178-0316 Fan 1
N/S 991-4039 Spark plug tester 1

- Frequently Replaced Parts

#PartDescription ReqNotesAvailability
1 162-0006 12V 18Ah AGM battery (size 6) 1
2 169-0016 Key switch assembly with two keys 1
3 991-1901 Key 1
4a 170-0052 Hour meter 1 (OEM)
4b 991-7137 Hour meter 1 (NON-OEM)
5a 170-3171 6 inch standard wheel 1
5b 991-8583 6 inch wheel 1
6 170-3009 Rear caster wheel (OBSOLETE) 1
8 170-3021 Handle grip tube 1
9 170-7893 Carrier strap - dust control 1
10a 996-5056 27 inch complete pad driver assembly (OBSOLETE) 1
10b 996-5058 21 inch complete pad driver assembly 1
11a 991-2206 Center-Lok 3 pad holder 1
11b 991-2201 Center-Lok II pad holder - right hand thread (black) 1
11c 991-2202 Big mouth pad holder set (blue) 1 (NON-OEM)
11d 991-8577 Pad retainer 1 (NON-OEM)
12 170-7889 Throttle cable (OBSOLETE) 1
13 272-7876 LP tank bracket weldment 1

- KAWASAKI FH500/FH541 - Muffler - Dust Bonnet - Emission System

#PartDescription ReqNotesAvailability
001a 170-3218 Kawasaki dust bonnet 1 (OEM)
001b 991-8592 Kawasaki bonnet filter 1 (NON-OEM)
002 170-3219 Bonnet cage 1
003 170-3237 Bonnet cage gasket 1
004 N/A Not available 1 (Emission system)
005a 170-3230 Exhaust manifold 1
005b 170-2005 Exhaust manifold 1 (Models 08992B and 08993B)
006 154-0175 Muffler clamp (OBSOLETE) 1
007a 270-0048 Vertical muffler non-catalytic 1
007b 170-3232 Vertical mount catalytic converting muffler (OBSOLETE) 1
008 N/A Not available 1 (Oxygen sensor)

- Pad Holders

#PartDescription ReqNotesAvailability
1 991-2214 Center-Lok II pad holder - left hand thread (red)
2a 991-2201 Center-Lok II pad holder - right hand thread (black) (Pad driver side female, Floor side male)
2b 991-8577 Pad retainer (Pad driver side male, Floor side female)
3a 991-2202 Big mouth pad holder set (blue) (includes 3 screws)
3b 991-2205 Deep lock ring and pad grip ring
4 991-2203 Big mouth pad holder male thread portion
5 991-2206 Center-Lok 3 pad holder (includes 3 screws)
6 996-0372 Big mouth pad holder (left hand thread)
7 N/A Not available
8 991-2209 Split retainer - pad holder ring (OBSOLETE)
9 N/A Not available (replaced by #3 991-2202)
10 991-2211 Center lock pad holding cup (male) (yellow) (OBSOLETE)

- Pads - 21 inch

#PartDescription ReqNotesAvailability
01 255-2140 21 inch aqua plus burnishing pad (pkg of 5)
02 255-2135 21 inch Armadillo concrete scrubbing pad (pkg of 5)
03 255-2164 21 inch Blue ace pad (pkg of 5)
04 255-2142 21 inch Blue Jay burnishing pad (pkg of 5)
05 255-2112 21 inch Cure white pad (pkg of 5) (OBSOLETE)
06 255-2177 21 inch Diamondback extreme stripping pad (pkg of 5)
07 255-2138 21 inch EHD Extra Heavy Duty Concrete Leveling Pad (pkg of 2
08 255-2121 21 inch gorilla lite burnishing pad (pkg of 5)
09 255-2150 21 inch gorilla spray buff/polish/burnish pad (pkg of 5)
10 255-2165 21 inch Heat concrete bonding pad (pkg of 5)
11 255-2130 21 inch jaguar burnishing pad (pkg of 5)
12 255-2167 21 inch Laminated 2001 Gorilla polish pad (pkg of 5)
13 255-2190 21 inch premium black stripping pad (pkg of 5)
14 255-2170 21 inch premium blue cleaning pad (pkg of 5)
15 255-2192 21 inch premium brown stripping pad (pkg of 5)
16 255-2180 21 inch premium green scrubbing pad (pkg of 5)
17 255-2160 21 inch premium red scrubbing pad (pkg of 5)
18 255-2152 21 inch premium tan polishing pad (pkg of 5)
19 255-2120 21 inch premium white polishing pad (pkg of 5)
20 255-2111 21 inch superspeed rubberized pad (pkg of 5)
21 255-2195 21 inch razorback stripping pad (pkg of 5)
22 255-2147 21 inch Redwood maroon floor prep pad (pkg of 10)
23 255-2155 21 inch Ruff non-abrasive brush pad (pkg of 2)
25 255-0164 21 inch Professional sand screen 120 grit (pkg of 10)
26 255-0165 21 inch Professional sand screen 180 grit (pkg of 10)
27 255-0162 21 inch Professional sand screen 60 grit (pkg of 10)
28 255-0256 21 inch Superscreen sand screen 100 grit (pkg of 10)
29 255-0257 21 inch Superscreen sand screen 120 grit (pkg of 10)
30 255-0258 21 inch Superscreen sand screen 180 grit (pkg of 10)
31 255-0255 21 inch Superscreen sand screen 60 grit (pkg of 10)
32 255-2124 21 inch Tiger carpet bonnet (pkg of 2)
33 255-9598 21 inch Diamond by Gorilla 11000 Grit (pkg of 2)
34 255-9595 21 inch Diamond by Gorilla 1500 Grit (pkg of 2)
35 255-9592 21 inch Diamond by Gorilla 200 Grit (pkg of 2)
36 255-9596 21 inch Diamond by Gorilla 3000 Grit (pkg of 2)
37 255-9593 21 inch Diamond by Gorilla 400 Grit (pkg of 2)
38 255-9594 21 inch Diamond by Gorilla 800 Grit (pkg of 2)
39 255-9597 21 inch Diamond by Gorilla 8000 Grit (pkg of 2)
40 255-9646 21 inch Diamond starter pack (1 of each grit)
41 255-2115 21 inch Duala clean and shine pad - low speed (pkg of 5)
42 255-2116 21 inch 2001 Duala clean and shine pad - high speed (pkg 5)

- Pads - 27 inch

#PartDescription ReqNotesAvailability
01 255-2740 27 inch aqua plus burnishing pad (pkg of 5)
02 255-2735 27 inch Armadillo concrete scrubbing pad (pkg of 5)
03 255-2770 27 inch Blue Ace pad (pkg of 5)
04 255-2742 27 inch Blue Jay burnishing pad (pkg of 5)
05 255-0065 27 inch Cure white pad (pkg of 5) (OBSOLETE)
07 255-2777 27 inch Diamondback extreme stripping pad (pkg of 5)
08 255-2738 27 inch EHD Extra Heavy Duty Concrete Leveling Pad (pkg of 2
09 255-2721 27 inch gorilla lite burnishing pad (pkg of 5)
10 255-2750 27 inch gorilla spray buff/polish/burnish pad (pkg of 5)
11 255-2765 27 inch Heat concrete bonding pad (pkg of 5)
12 255-2730 27 inch jaguar burnishing pad (pkg of 5)
13 255-2767 27 inch Laminated 2001 Gorilla polish pad (pkg of 5)
14 255-2769 27 inch Micropolish polishing and burnishing pad (pkg of 2)
15 255-2790 27 inch premium black stripping pad (pkg of 5)
17 255-2764 27 inch premium blue cleaning pad (pkg of 5)
18 255-2792 27 inch premium brown stripping pad (pkg of 5)
19 255-2780 27 inch premium green scrubbing pad (pkg of 5)
20 255-2760 27 inch premium red scrubbing pad (pkg of 5)
21 255-2752 27 inch premium tan polishing pad (pkg of 5)
22 255-2720 27 inch premium white polishing pad (pkg of 5)
23 255-2795 27 inch razorback stripping pad (pkg of 5)
24 255-2747 27 inch Redwood maroon floor prep pad (pkg of 10)
25 255-2711 27 inch superspeed rubberized pad (pkg of 5)
26 255-9626 27 inch Diamond by Gorilla 11000 Grit (pkg of 2)
27 255-9623 27 inch Diamond by Gorilla 1500 Grit (pkg of 2)
28 255-9620 27 inch Diamond by Gorilla 200 Grit (pkg of 2)
29 255-9624 27 inch Diamond by Gorilla 3000 Grit (pkg of 2)
30 255-9621 27 inch Diamond by Gorilla 400 Grit (pkg of 2)
31 255-9622 27 inch Diamond by Gorilla 800 Grit (pkg of 2)
32 255-9625 27 inch Diamond by Gorilla 8000 Grit (pkg of 2)
33 255-9650 27 inch Diamond starter pack (1 of each grit)
34 255-2715 27 inch Duala clean and shine pad - low speed (pkg of 5)
35 255-2716 27 inch 2001 Duala clean and shine pad - high speed (pkg 5)

Decal Assembly

#PartDescription ReqNotesAvailability
1 472-7462 DECAL-LPG CAUTION 1
2 472-7463 DECAL-MAINTENANCE 1
3 472-7464 DECAL-WARNING 1
4 170-3174 Ventilation danger decal 1
5 270-0036 PBU decal 1

Electrical Assembly

#PartDescription ReqNotesAvailability
2 999-0123 Washer 1/4 SAE flat zinc plated 8
3 999-0522 Screw 1/4-20 x 1/2 pan head phillips stainless steel 2
5 999-0830 Screw 1/4-20 x 1 hex head plain finish 4
6 999-0294 Nut 1/4-20 hex nylon lock type NE stainless steel 4
11 372-3697 Heyco snap bushing (OBSOLETE) 1
14 170-3062 12V starter solenoid 1
15 270-8072 Key switch assembly with key 1
16 162-0006 12V 18Ah AGM battery (size 6) 1
17 170-3060 Battery box 1
19a 170-0052 Hour meter 1 (OEM)
19b 991-7137 Hour meter 1 (NON-OEM)
20 170-6013 1/4 terminal 1
21 992-0001 Velcro loop (sold by the inch) 12 in (needs cut into 2 6 inch pieces)
N/S 170-7882 PBU Wiring harness 1
N/S 170-3715 Clip terminal 1
N/S 170-7883 Insulation boot 3
N/S 170-7884 Dead stop CO detector 1
N/S 170-3108 Fuse holder 1
N/S 170-7885 15amp fuse 1

Engine Assembly

#PartDescription ReqNotesAvailability
0a 472-7668 ENGINE KIT-603CC CAT-11 1 (includes 1-2, 3b-13, 14b-16) (only used on models 56381402, 56381407 and 56381454)
0b 472-7478 ENGINE KIT-603CC MUFF 1 (includes 1-3a, 4-14a, 15-16) (only used on models 56381404, 56381405 and 56381406)
1 372-3698 Elbow (OBSOLETE) 1
2 N/A Not available 1 (kawasaki engine)
3a 472-7448 CARBURETOR-LPG 1 (only used on models 56381404, 56381405 and 56381406)
3b 472-7666 CARBURETOR-LP-11 1 (only used on models 56381402, 56381407 and 56381454)
4 472-7453 FITTING-1/8 BARB X 10-32 1
5 272-3351 P clamp 2
6 170-3221 Oil pressure switch, 3-prong molded plug 1
7 372-3186 Adapter 1
9 170-3238 Street elbow 1
10 372-1226 1/2 inch drain hose 1
11 154-0042 Oil drain valve kit 1
12 272-6584 Dust bonnet 1
13 472-7450 GASKET-CARBURETOR 1
14a 472-7459 ELBOW-90 BARB W/ORIFICE 1 (only used on models 56381404, 56381405 and 56381406)
14b 472-7667 ELBOW-90 BARB W/ ORIFICE-11 1 (only used on models 56381402, 56381407 and 56381454)
15 472-7833 BONNET RETAINER 1
16 272-2117 Nylon tree push-in rivet 1
N/S 178-0254 Oil filter 1
N/S 991-6027 Oil filter 1 (NON-OEM)
N/S 166-0008 Spark plug (Kawasaki FS481V) 2
N/S 178-0264 Ignition coil assembly Kawasaki FS481V 2
N/S 991-7143 Ignition coil assembly 2 (NON-OEM)
N/S 178-0256 Air filter 1
N/S 472-7677 BRACKET-MUFFLER 1
N/S 178-0255 Air pre-filter 1
N/S 991-6028 Air pre-filter 1 (Non-Oem)
N/S 272-7307 Starter 1
N/S 272-7283 Exhaust gasket 1
N/S 472-7468 ELBOW-A/C 1
N/S 472-7469 HOSE-BREATHER 1
N/S 189-3090 Oil dipstick 1
N/S 472-7480 GASKET KIT-FS481V 1

Engine System Assembly

#PartDescription ReqNotesAvailability
1 160-0054 45 degree elbow fitting 2
2 160-0052 Fitting 1/4 barb x 1/4mp 1
4 999-1032 Screw 1/4-20 x 5/8 hex head stainless steel 1
7 372-2180 Screw 3/8-16 x 1/2 3
8 999-1133 Bolt M8-1.25 x 20mm hex head full thread plain 2
10 999-0395 Screw 1/4-20 x 5/8 button head socket plain finish 2
11 997-2004 Hose clamp 2
12 272-7274 Hose clamp 1
13 272-7275 Female coupler 1
14 272-7276 Regulator (OBSOLETE) 1
15 272-7277 12V Lock off assembly (OBSOLETE) 1
16 272-7278 90° male elbow (OBSOLETE) 1
17 572-4027 Hose 1
18a 472-7668 ENGINE KIT-603CC CAT-11 1 (only used on models 56381402, 56381407 and 56381454)
18b 472-7478 ENGINE KIT-603CC MUFF 1 (only used on models 56381404, 56381405 and 56381406)
19 472-7457 MANIFOLD-EXHAUST 1
20a 272-7250 Catalyst muffler 1 (only used on models 56381402, 56381407 and 56381454)
20b 272-7280 Muffler 1 (only used on models 56381404, 56381405 and 56381406)
22 272-7281 Vac hose 1
24 170-3180 3/8 inch propane hose 1
25 169-0142 Muffler plug 1
26 170-3181 Check valve 1
28 999-0060 Washer 1/4 split lock plain finish 1
29a 161-0004 Steel propane tank 1
29b 161-0003 Aluminum propane tank 1 (polished)
29c 370-6878 TANK LP ALUM 80 1 (gray)
30 272-7283 Exhaust gasket 1
31 272-7284 Muffler clamp 1
32 999-0659 Washer 3/8 medium split lock stainless steel 3
33 999-0028 Washer 5/16 split lock plain finish 2
34 472-8012 ADAPTER-.25MPT X .25FPT-BRASS (OBSOLETE) 1
N/S 272-7282 Exhaust clamp 1

Frame Assembly - Standard

#PartDescription ReqNotesAvailability
1 999-0200 Bolt 1/2-13 x 1 1/4 hex head 2
2 999-0390 Bolt 3/8-16 x 2 1/2 hex hd grade 5 zinc plated 2
3 999-0114 Washer 1/2 SAE flat 2
4 999-0024 Washer 5/16 flat stainless steel 16
5 999-1436 Bolt 1/4-20 x 1 3/4 hex stainless steel 1 (only used on models 56381402, 56381401, 56381405 and 56381407)
6 999-0031 Bolt 5/16-18 x 1 hex head grade 5 zinc plated 4
7 999-1825 Screw 5/16-18 x 1 1/2 flat head socket SS 8
8 999-0211 Nut 5/16-18 hex nylon insert lock zinc plated 12
9 999-0294 Nut 1/4-20 hex nylon lock type NE stainless steel 1 (only used on models 56381402, 56381401, 56381405 and 56381407)
10 999-0388 Nut 7/16-14 flange lock serrated zinc plated 1
11 999-0324 Nut 3/8-16 nylon insert lock jam zinc plated 2
13 272-9279 Throttle cable 1 (only used on models 56381402, 56381401, 56381405 and 56381407)
14a 472-7466 STRIP-21 BUMPER (OBSOLETE) 1
14b 472-7467 STRIP-27 BUMPER 1
15a 170-3171 6 inch standard wheel 2 (OEM)
15b 991-8583 6 inch wheel 2 (NON-OEM)
16 170-3156 Propane tank holder weldment 1
17 999-0391 Washer 1/2 internal/external star lock 2
18 992-0001 Velcro loop (sold by the inch) 3 in
19 170-3021 Handle grip tube 1
20 170-3157 Switch and meter guard (OBSOLETE) 1
21a 170-7872 21 inch frame (gray) 1
21b 170-3154 27 inch frame 1
22 170-3022 Upper handle (OBSOLETE) 1
23 170-3009 Rear caster wheel (OBSOLETE) 1
24 170-3166 3 hole wheel bracket (OBSOLETE) 2
25 170-7889 Throttle cable (OBSOLETE) 1 (only used on models 56381406 and 56381454)
26 999-0453 Screw 8-32 x 1/2 pan head phillips thread forming zinc 1 (only used on models 56381406 and 56381454)
27 170-3018 Lever bar 1 (only used on models 56381406 and 56381454)

NON-OEM Dust Bonnet and Cage Option

#PartDescription ReqNotesAvailability
1 991-9014 Kawasaki dust bonnet 1
2a 160-0198 3 tab filter cage with support ring for 17HP (metal) 1 (includes 2b)
2b 160-0297 Filter cage support ring for 17HP (converts 3 tab/4 tab) 1
3 999-0250 Bolt M5-.8 x 10mm hex head full thread 3 (to secure cage to ring)
4 999-0740 Nut M5-.8 hex stainless steel 3 (to secure cage to ring)
5 999-0673 Nut M6-1 acorn zinc plated 4 (to secure ring to engine)
6 999-0123 Washer 1/4 SAE flat zinc plated 7 (to secure cage and ring to engine)
7 160-0123 3 tab filter cage for 18HP (metal) 1

Pad Drive Assembly - 21 inch

#PartDescription ReqNotesAvailability
1 999-0390 Bolt 3/8-16 x 2 1/2 hex hd grade 5 zinc plated 1
2 181-0079 Screw 5/16-18 x 5/8 socket set lock 4 (qty 2 for models with clutch plate)
3 999-0120 Washer 3/8 SAE flat 1
4 172-2588 Key 1
5 999-1416 Washer 7/16 flat stainless steel 4
6 270-0047 21 inch pad driver flex 1
7 170-8944 01-09.5j21 1
8 999-0678 Screw 8-18 x 5/8 pan head self-drilling stainless steel 3
9 370-4874 SCR-HEX 7/16-20 X 1.00 1 (without clutch)
10 999-0043 Bolt 7/16-20 x 1 1/4 hex head grade 5 zinc plated 4
11 999-0854 Washer 3/4 external lock zinc plated 1
12 170-3140 3.5 x 1 pulley 1 (without clutch)
13 170-3071 6 inch pulley (OBSOLETE) 1 (without clutch)
14a 991-0023 B38 Belt 1 (without clutch)
14b 991-0042 B-41 belt 1 (with clutch)
15 255-2152 21 inch premium tan polishing pad (pkg of 5) 1
16 999-0659 Washer 3/8 medium split lock stainless steel 1
17 999-0538 Screw 1/4-20 x 1 flat head slotted stainless steel 6
18 170-1996 Bearing assembly (OBSOLETE) 1
19 270-0046 Shaft plate flex 1
20 991-2206 Center-Lok 3 pad holder 1
21 270-0041 Spacer 1
22 170-3075 Square keyway 1
23 999-0044 Washer 7/16 medium split lock 5
24 154-0016 Bottom clutch spacer 1
25 164-1015 Washer 1 x .13 thick flat 7 (with clutch)
26 999-0853 Screw 7/16-20 x 2 hex head grade 5 plain finish 1 (with clutch)
27 170-3142 Centrifugal clutch 1 (with clutch)
N/S 170-0026 Drive shaft (OBSOLETE) 1
N/S 270-0045 Taper housing (OBSOLETE) 1
N/S 991-1506 Sealed ball bearing 6205 2
N/S 997-2201 1 inch external snap ring 2

Pad Drive Assembly - 27 inch

#PartDescription ReqNotesAvailability
1 999-0390 Bolt 3/8-16 x 2 1/2 hex hd grade 5 zinc plated 1
2a 999-0024 Washer 5/16 flat stainless steel 12 (without clutch)
2b 999-0123 Washer 1/4 SAE flat zinc plated 12 (with clutch)
3 181-0079 Screw 5/16-18 x 5/8 socket set lock 4 (qty 2 for models with clutch plate)
4 999-0120 Washer 3/8 SAE flat 1
5 999-0211 Nut 5/16-18 hex nylon insert lock zinc plated 12
6 172-2588 Key 1
7 999-1416 Washer 7/16 flat stainless steel 4
8 472-7986 PAD-BEIGE-27-2/CS 1
9 170-6229 27 inch pad gripper (OBSOLETE) 1
10 170-8944 01-09.5j21 1
11 370-4874 SCR-HEX 7/16-20 X 1.00 1
12 999-0043 Bolt 7/16-20 x 1 1/4 hex head grade 5 zinc plated 4
13 999-0854 Washer 3/4 external lock zinc plated 1
14 170-3101 Aluminum pop rivet 11
16 170-3094 Belting coupler 1
17 170-3105 27 inch pad driver assembly 1
18 170-3095 Coupling spacer (OBSOLETE) 6
19 170-3093 Elevator bolt 12
20a 991-0009 BX51 belt 1 (without clutch)
20b 991-0028 BX54 belt 1 (with clutch)
21 999-0659 Washer 3/8 medium split lock stainless steel 1
22 170-7878 Bearing assembly (OBSOLETE) 1
23 991-2206 Center-Lok 3 pad holder 1
24 270-0041 Spacer 1
25 170-3075 Square keyway 1
26 999-0044 Washer 7/16 medium split lock 5
27a 160-0135 Pulley 8.8 x 1 1 (without clutch)
27b 170-0024 10 inch pulley 1 (with clutch)
28 170-3092 Shaft plate steel (OBSOLETE) 1
29 154-0016 Bottom clutch spacer 1
N/S 170-0026 Drive shaft (OBSOLETE) 1
N/S 170-3149 Bearing assembly with shaft, housing, bearing and snap ring 1
N/S 991-1506 Sealed ball bearing 6205 2
N/S 997-2201 1 inch external snap ring 2

Wiring Diagram

#PartDescription ReqNotesAvailability
N/A Not available 1 (voltage regulator rectifier)
N/A Not available 1 (alternator stator)
162-0006 12V 18Ah AGM battery (size 6) 1
170-3062 12V starter solenoid 1
272-7307 Starter 1
166-0008 Spark plug (Kawasaki FS481V) 2
a 178-0264 Ignition coil assembly Kawasaki FS481V 2
b 991-7143 Ignition coil assembly 2 (NON-OEM)
170-7885 15amp fuse 1
170-3221 Oil pressure switch, 3-prong molded plug 1
270-8072 Key switch assembly with key 1
272-7277 12V Lock off assembly (OBSOLETE) 1
a 170-0052 Hour meter 1
b 991-7137 Hour meter 1 (NON-OEM)