- Batteries, Brushes and Chargers

#PartDescription ReqNotesAvailability
162-0003 6V 225Ah wet battery (SNSR) 4 (WET)
162-0043 6V 224Ah AGM battery (Group GC2) (SNSR) 4 (AGM)
174-6603 24V on board battery charger kit 1
274-8749 BRUSH 85CM PPN 0.5 1
274-8750 BRUSH 85CM SYNTHETIC K 901 1
274-9043 BRUSH 85CM SIC PA 6 GRAY 600 GRIT 1
274-8751 BRUSH 85CM PPN 0.8 1
274-9044 BRUSH 85CM HVY DUTY SIC PA6 GRAY 180 GR 1
274-9045 BRUSH 85CM EXT HVY DUTY SIC PA 6.12 GREE 1
274-8415 PAD DRIVER 85CM WITH CENTER LOCK 1

- Frequently Replaced Parts

#PartDescription ReqNotesAvailability
162-0003 6V 225Ah wet battery (SNSR) 4 (WET)
162-0043 6V 224Ah AGM battery (Group GC2) (SNSR) 4 (AGM)
174-6603 24V on board battery charger kit 1
174-8940 18/3 power cord 1 (OEM)
991-5007 18/3 replacement power cord 50 foot (black) 1 (NON-OEM)
998-0010 Battery jumper cable - ring type (red) 1
174-8914 Key switch 1
174-7079 Key (set of 2) 1
174-9633 24V solenoid valve 1
174-3670 Water filter assembly 1
174-7082 Squeegee blade urethane front 1
174-7083 Rear polyurethane blade 1
274-9976 Squeegee vacuum hose 1
274-7139 Recovery tank lid assembly 1
174-8923 Gasket (sold by the foot) 5 ft
174-8455 Drain hose assembly 1
174-8495 24V vacuum motor 1
174-8893 Carbon brush (set of 4) 1
274-8749 BRUSH 85CM PPN 0.5 1
274-8750 BRUSH 85CM SYNTHETIC K 901 1
274-9043 BRUSH 85CM SIC PA 6 GRAY 600 GRIT 1
274-8751 BRUSH 85CM PPN 0.8 1
274-9044 BRUSH 85CM HVY DUTY SIC PA6 GRAY 180 GR 1
274-9045 BRUSH 85CM EXT HVY DUTY SIC PA 6.12 GREE 1
274-8415 PAD DRIVER 85CM WITH CENTER LOCK 1
274-8415 PAD DRIVER 85CM WITH CENTER LOCK 2
174-8901 Center lock 1
991-2214 Center-Lok II pad holder - left hand thread (red) 1
991-2201 Center-Lok II pad holder - right hand thread (black) 1
991-2206 Center-Lok 3 pad holder 1

- Pad Holders

#PartDescription ReqNotesAvailability
1 991-2214 Center-Lok II pad holder - left hand thread (red)
2a 991-2201 Center-Lok II pad holder - right hand thread (black) (Pad driver side female, Floor side male)
2b 991-8577 Pad retainer (Pad driver side male, Floor side female)
3a 991-2202 Big mouth pad holder set (blue) (includes 3 screws)
3b 991-2205 Deep lock ring and pad grip ring
4 991-2203 Big mouth pad holder male thread portion
5 991-2206 Center-Lok 3 pad holder (includes 3 screws)
6 996-0372 Big mouth pad holder (left hand thread)
7 N/A Not available
8 991-2209 Split retainer - pad holder ring (OBSOLETE)
9 N/A Not available (replaced by #3 991-2202)
10 991-2211 Center lock pad holding cup (male) (yellow) (OBSOLETE)

- Pads - 17 inch

#PartDescription ReqNotesAvailability
01 255-1740 17 inch aqua plus burnishing pad (pkg of 5)
02 255-1735 17 in Armadillo concrete scrubbing pad (pkg of 5) (OBSOLETE)
03 255-1764 17 inch Blue ace pad (pkg of 5)
04 255-1742 17 inch Blue Jay burnishing pad (pkg of 5)
05 255-1712 17 inch Cure white pad (pkg of 5) (OBSOLETE)
06 255-1777 17 inch Diamondback extreme stripping pad (pkg of 5)
07 255-1738 17 inch EHD Extra Heavy Duty Concrete Leveling Pad (pkg of 2
08 255-1721 17 inch gorilla lite burnishing pad (pkg of 5)
09 255-1750 17 inch gorilla spray buff/polish/burnish pad (pkg of 5)
10 255-1765 17 inch Heat concrete bonding pad (pkg of 5)
11 255-1730 17 inch jaguar burnishing pad (pkg of 5)
12 255-1767 17 inch Laminated 2001 Gorilla polish pad (pkg of 5)
13 255-1768 17 inch Microclean daily cleaning pad (pkg of 2) (OBSOLETE)
14 255-1769 17 inch Micropolish polishing and burnishing pad (pkg of 2)
15 255-1790 17 inch premium black stripping pad (pkg of 5)
16 255-1770 17 inch premium blue cleaning pad (pkg of 5)
17 255-1792 17 inch premium brown stripping pad (pkg of 5)
18 255-1780 17 inch premium green scrubbing pad (pkg of 5)
19 255-1760 17 inch premium red scrubbing pad (pkg of 5)
20 255-1752 17 inch premium tan polishing pad (pkg of 5)
21 255-1720 17 inch premium white polishing pad (pkg of 5)
22 255-1711 17 inch superspeed rubberized pad (pkg of 5)
23 255-1795 17 inch razorback stripping pad (pkg of 5)
24 255-1747 17 inch Redwood maroon floor prep pad (pkg of 10)
25 255-1755 17 inch Ruff non-abrasive brush pad (pkg of 2)
26 255-1723 17 inch sand screen driver pad (pkg of 2)
27 255-0139 17 inch Professional sand screen 100 grit (pkg of 10)
28 255-0019 17 inch Professional sand screen 120 grit (pkg of 10)
29 255-0140 17 inch Professional sand screen 150 grit (pkg of 10)
30 255-0141 17 inch Professional sand screen 180 grit (pkg of 10)
31 255-0142 17 inch Professional sand screen 220 grit (pkg of 10)
32 255-0143 17 inch Professional sand screen 400 grit (pkg of 10)
33 255-0138 17 inch Professional sand screen 60 grit (pkg of 10)
34 255-0018 17 inch Professional sand screen 80 grit (pkg of 10)
35 255-0225 17 inch Superscreen sand screen 100 grit (pkg of 10)
36 255-0226 17 inch Superscreen sand screen 120 grit (pkg of 10)
37 255-0227 17 inch Superscreen sand screen 150 grit (pkg of 10)
38 255-0228 17 inch Superscreen sand screen 180 grit (pkg of 10)
39 255-0229 17 inch Superscreen sand screen 220 grit (pkg of 10)
40 255-0230 17 inch Superscreen sand screen 400 grit (pkg of 10)
41 255-0223 17 inch Superscreen sand screen 60 grit (pkg of 10)
42 255-0224 17 inch Superscreen sand screen 80 grit (pkg of 10)
43 255-1724 17 inch Tiger carpet bonnet (pkg of 2)
44 255-9570 17 inch Diamond by Gorilla 11000 Grit (pkg of 2)
45 255-9567 17 inch Diamond by Gorilla 1500 Grit (pkg of 2)
46 255-9564 17 inch Diamond by Gorilla 200 Grit (pkg of 2)
47 255-9568 17 inch Diamond by Gorilla 3000 Grit (pkg of 2)
48 255-9565 17 inch Diamond by Gorilla 400 Grit (pkg of 2)
49 255-9566 17 inch Diamond by Gorilla 800 Grit (pkg of 2)
50 255-9569 17 inch Diamond by Gorilla 8000 Grit (pkg of 2)
51 255-9642 17 inch Diamond starter pack (1 of each grit)
52 255-1782 17 inch Turbostrip segmented rotary pad (pkg of 4)
53 255-1715 17 inch Duala clean and shine pad - low speed (pkg of 5)
54 255-1716 17 inch 2001 Duala clean and shine pad - high speed (pkg 5)

Battery Charger Assembly

#PartDescription ReqNotesAvailability
0 174-3951 Charger hardware 1 (includes 1-12)
1a 174-8940 18/3 power cord 1 (OEM)
1b 991-5007 18/3 replacement power cord 50 foot (black) 1 (NON-OEM)
2 174-8941 Lens flange screw 2
3 174-3521 Cap 2 (attaches to 12 with loctite)
4 174-8942 Cord attachment cover 1
5 174-6603 24V on board battery charger kit 1
6 174-8943 Tension band 1
7 174-8944 Hose 3
8 997-2102 Cable tie 8
9 174-6185 Cable tie large 1
12 174-8946 Cable retainer 1
N/S 274-6219 WIRING HARNESS W6 C 1
N/S 174-8457 Wiring harness 1

Battery Tray Assembly

#PartDescription ReqNotesAvailability
1 174-4224 Sheet metal 1
2 174-4223 Battery tray 1

Brush Pressure Adjustment Assembly

#PartDescription ReqNotesAvailability
0 174-4078 Brush pressure adjustment 1 (includes 1-13)
1 274-4906 PEDAL 1
2 174-9665 S-bolt 1
3 174-9655 Clevis yoke 1
4 999-1424 Nut M8-1.25 hex stainless steel 1
5 174-9664 Eye bolt 1
6 174-9662 Tension spring 1
7 999-0022 Bolt M10-1.5 x 30mm hex head full thread 1
8 174-3486 Washer 1
9 174-9656 Pressure adjustment bracket 1
10 999-1428 Nut M10-1.5 hex zinc finish 1
11 174-6567 Brush pressure decal 1
12 174-9619 Rubber washer 1
13 174-9654 Anti-slip pedal decal 1

Chassis Assembly

#PartDescription ReqNotesAvailability
1 174-8967 Grommet 1
2 274-8943 CHASSIS 1
3 274-1312 LENS FLANGE SCREW 2
4 999-9097 Washer M8 flat stainless steel 4
5 174-9625 Nut M8-1.25 eye zinc 2
6 174-9630 Washer M9 conical spring with tooth 10
7 999-0784 Screw M8-1.25 x 16mm hex head stainless steel 8
8 174-9641 Screw M10-1.5 x 60mm flat head 1
9 174-9658 Pedal pivot bushing 1
10 274-5593 LIFTING PEDAL 1
11 174-9621 Washer M17 flat 1
12 174-4078 Brush pressure adjustment 1
13 999-1312 Screw M6-1 x 20mm hex head stainless steel 2
14 174-8292 Cable guide bushing 1
15 174-8973 Pedal locking bracket 1
16 999-1261 Washer M6 flat stainless steel 4
17 999-0497 Nut M6-1 nylon insert lock stainless steel 2
18 999-1897 Screw M3-.5 x 20mm hex head 2
19 999-1521 Washer M3 flat stainless steel 2
20 174-6576 Switch mount bracket 1
21 174-8931 Micro switch 1
22 174-8930 Threaded switch mount plate 1
23 174-8972 Cable clip 2
24 999-0501 Bolt M8-1.25 x 25mm hex head full thread stainless steel 2
25 999-0900 Screw M8-1.25 x 18mm hex head stainless steel 1
26 174-4088 Spacer sleeve 2
27 999-1383 Screw M6-1 x 16mm hex head stainless steel 2

Console Assembly

#PartDescription ReqNotesAvailability
0 274-8493 DASH PANEL, E24 1 (includes 1-7)
1 274-8927 Display panel console 1
2 174-8911 Ribbon cable 1
3 174-8912 Screw 4
4 174-3488 Console back 1
5 174-8913 Cable 1
6 174-8914 Key switch 1
7 174-7079 Key (set of 2) 1

Control Panel Assembly

#PartDescription ReqNotesAvailability
0 274-9283 OPERATING CONSOLE ASSY, E24 1 (includes 1-9)
1 374-2110 SC-BHCS W/ FLANGE M8 X 1.25 X 12 304SS 4
2 174-6584 Handle bar 1
3 274-8493 DASH PANEL, E24 1
4 174-8921 Panel mount bracket 1
5 999-1514 Screw M6-1 x 10mm button head socket stainless steel 4
6 999-9089 Washer M4 flat stainless steel 4
7 174-8902 Self tapping screw 4
8 174-8922 Bail system 1
9 999-0496 Nut M8-1.25 nylon insert lock stainless steel 2

Decal Assembly

#PartDescription ReqNotesAvailability
1 174-8937 Decal 1
2 174-4187 E33 decal 2
3 274-1477 DECAL, MINUTEMAN W/SWOOSHES, GREY 1
4 174-4188 Type plate 1
5 274-2916 BLIND RIVET 2

Electrical Assembly

#PartDescription ReqNotesAvailability
1 999-1514 Screw M6-1 x 10mm button head socket stainless steel 5
2 174-8981 Cover plate 1
3 174-8982 Edge protection 2 in
4 174-4225 Control board complete assembly 1
5 999-1261 Washer M6 flat stainless steel 1
6 999-0497 Nut M6-1 nylon insert lock stainless steel 1
7 174-3494 Cable sleeve 1
8 174-3495 Cover plate bracket 1
9 174-8494 Screw M6-1 x 25mm with flange 2
10 174-8984 Electrical panel cover 1
11 274-2565 CLAMPING PLATE 1
12 174-8983 Bushing 2
13 999-9097 Washer M8 flat stainless steel 2
14 999-0785 Screw M8-1.25 x 30mm hex head stainless steel 2
15 174-3496 Self tapping screw 1
16 999-1594 Washer M5 external lock stainless steel 1

Electrovalve Assembly

#PartDescription ReqNotesAvailability
0 174-4128 Water supply assembly 1 (includes 1-10)
1 374-2864 SCREWED ANGLE FITTING 1
2 174-1628 Hose clamp 4
3 174-9631 PVC hose (Sold by the Meter) 1
4 174-9633 24V solenoid valve 1
5 174-8955 Hose barb elbow fitting 2
6 174-9631 PVC hose (Sold by the Meter) 1
7 999-9104 Screw M4-.7 x 10mm hex head stainless steel 2
8 999-9089 Washer M4 flat stainless steel 2
9 374-2273 RETAINER 1
10 174-4135 Sealing band 1

Lift Pedal Assembly

#PartDescription ReqNotesAvailability
0 274-5593 LIFTING PEDAL 1 (includes 1-9)
1 174-8887 Lifting pedal 1
2 174-8888 Washer 2
3 174-8889 Rod weldment 1
4 174-8890 Cotter pin 1
5 999-1428 Nut M10-1.5 hex zinc finish 1
6 174-9653 Clevis yoke 1
7 174-9663 S-bolt 1
8 174-9619 Rubber washer 2
9 174-9654 Anti-slip pedal decal 1

Lifting Spring Assembly

#PartDescription ReqNotesAvailability
1 174-4167 Angle 1
2 999-0496 Nut M8-1.25 nylon insert lock stainless steel 4
3 999-9097 Washer M8 flat stainless steel 6
4 999-0784 Screw M8-1.25 x 16mm hex head stainless steel 2
5 174-4168 Gas pressure spring 1
6 999-0501 Bolt M8-1.25 x 25mm hex head full thread stainless steel 2
7 174-4169 Retainer 1
8 274-4456 BELT 1
9 999-9092 Screw M8-1.25 x 20mm hex head stainless steel 1
10 174-4171 Angle 1

Lower Chassis Assembly

#PartDescription ReqNotesAvailability
1 174-4118 Water supply 1
2 999-1261 Washer M6 flat stainless steel 4
3 999-9116 Screw M6-1 x 12mm hex head stainless steel 2
4 999-1514 Screw M6-1 x 10mm button head socket stainless steel 1
5 174-8971 Bushing 1
6 999-0496 Nut M8-1.25 nylon insert lock stainless steel 1
7 999-9097 Washer M8 flat stainless steel 9
8 274-7616 PUMP, ASSEMBLY 24VDC 1
9 174-4123 QC-FEMALE 18G 0.5-1.5 mmq .250 NON-INS 1
10 174-4124 CONNECT-1 POS POSITIVE LOCK MALE- RECEPT 1
11 174-4125 Female connector 1
12 174-4126 QC-MALE 14G (1.5-2.5 mmq) .250 NON-INS 1
13 999-9100 Washer M5 flat stainless steel 1
14 174-4128 Water supply assembly 1
15 999-0497 Nut M6-1 nylon insert lock stainless steel 2
16 174-8941 Lens flange screw 2
17 174-4130 Steering roller 2 (soft construction)
18 174-9659 Tension spring 1
19 174-9664 Eye bolt 1
20 999-1551 Nut M8-1.25 hex jam zinc plated 1
21 174-9660 Pivot 1
22 174-3504 Connection bracket 1
23 174-4133 Bracket 2
24 274-3341 SCREW, SOCKET HEAD 8
25 274-7979 STEERING ROLLER(DOUBLE WHEEL-HARD DRK GR 2 (hard construction)
27 274-4515 LINKAGE 1

Rear Chassis Assembly

#PartDescription ReqNotesAvailability
1 174-8993 Transaxle mounting bracket 2
2 999-9097 Washer M8 flat stainless steel 10
3 999-0501 Bolt M8-1.25 x 25mm hex head full thread stainless steel 1
4 274-0028 BEARING BLOCK, NYLON 4 (after February 2008) (to exchange older blocks order 21)
5 999-1692 Screw M8-1.25 x 50mm hex stainless steel 4
6 999-9159 Bolt M8-1.0 x 100mm hex cap 4
7 174-8888 Washer 2
8 274-0632 BLT-HH M10 X 1.5 X 20 STL ZD 8.8 DIN 933 2
9 274-7604 LEVER WELDMENT 1
10 174-3546 Transaxle hub 2
11 174-8995 Rim 2
12 274-8023 TIRE SOFT (NON MARKING) 2
13 174-8996 Rim 2
14 174-9637 Bolt M8-1.25 x 20mm hex head flange 8
15 174-8990 Protection cap 2
16 999-1122 Nut M12-1.75 hex nylon insert lock stainless steel 2
17 374-0693 Washer M13 2
18 999-0497 Nut M6-1 nylon insert lock stainless steel 8
19 999-1261 Washer M6 flat stainless steel 8
20 174-4117 Traction drive 1
21 174-3549 Block assembly 1 (includes 4-5, 22) (it is necessary to change all 4 blocks)
22 999-9097 Washer M8 flat stainless steel 4 (also included in 21)

Recovery Tank Assembly

#PartDescription ReqNotesAvailability
1 274-7139 Recovery tank lid assembly 1
2 174-3515 Screw cylinder head 4
3 999-1261 Washer M6 flat stainless steel 4
4 174-8923 Gasket (sold by the foot) 5 ft
5 174-9629 Screw M5 x 20mm EJOT PT stainless steel 4
6 174-8924 Filter 1
7 174-4165 Recovery tank 1
8 174-9630 Washer M9 conical spring with tooth 6
9 999-0784 Screw M8-1.25 x 16mm hex head stainless steel 6
10 274-9976 Squeegee vacuum hose 1
11 174-8926 Hose support 1
12 999-1514 Screw M6-1 x 10mm button head socket stainless steel 2
13 174-4166 Lifting device 1

Retainer Assembly

#PartDescription ReqNotesAvailability
0 174-4225 Control board complete assembly 1 (includes 1-25)
1 174-6185 Cable tie large 4
2 997-2102 Cable tie 8
3 174-8962 Webbing 1
4 999-1261 Washer M6 flat stainless steel 2
5 999-1383 Screw M6-1 x 16mm hex head stainless steel 2
6 174-3518 Controller bracket 1
7 174-8958 Edge protection (Sold by the foot) 5 in
8 999-0953 Nut M5-.8 hex nylon insert lock stainless steel 2
9 999-9100 Washer M5 flat stainless steel 4
10 174-9620 Bolt M5-.8 x 16 hex head 2
11 274-8607 CONTACTOR 1
12 174-8291 Nut cover safety cap M8 4
13 174-3494 Cable sleeve 1
14 174-9619 Rubber washer 4
15 174-8963 Protective cap 2
16 999-0497 Nut M6-1 nylon insert lock stainless steel 1
17 999-1261 Washer M6 flat stainless steel 1
18 174-6614 Controller 1
19 274-1693 FUSE, STRIP 125AMP 80VOLT- MAIN 1
20 174-8965 50amp fuse 1
21 174-3520 Fuse 1
22 174-8966 2amp fuse 1
23 174-8958 Edge protection (Sold by the foot) 1 in
24 174-3521 Cap 2
25 374-0610 FUSE, 5AMP 32VOLT 1

Rocker Assembly

#PartDescription ReqNotesAvailability
1 174-4193 Screw 2
2 999-9097 Washer M8 flat stainless steel 7
3 999-1120 Nut M10-1.5 nylon insert lock stainless steel 2
4 274-9385 WEIGHT 1
5 999-0784 Screw M8-1.25 x 16mm hex head stainless steel 5
6 174-4194 Covering 1
7 174-4195 Bolt 2
8 174-8991 Cotter pin 2
9 374-0693 Washer M13 8
10 174-8974 Bushing 4
11 274-7130 ROCKER 1
12 274-0641 BACKING FILM 1
13 997-2102 Cable tie 3
14 174-6185 Cable tie large 2
15 174-4196 Retainer 1
16 999-1372 Bolt M10-1.5 x 25mm hex head stainless steel 2
17 174-8888 Washer 2
18 174-4197 Disk 4

Scrub Deck Assembly - Disk - Part 1

#PartDescription ReqNotesAvailability
1 174-4189 Motor 2
2 174-8892 Fitting key 2
3 174-8893 Carbon brush (set of 4) 1
4 174-4190 Housing 1
5 274-6006 CARRIER 2
6 174-8895 Washer 2
7 999-9092 Screw M8-1.25 x 20mm hex head stainless steel 2
8 274-8415 PAD DRIVER 85CM WITH CENTER LOCK 2 (includes 19-21)
9 999-9097 Washer M8 flat stainless steel 4
10 999-0785 Screw M8-1.25 x 30mm hex head stainless steel 8
11 174-8896 Sheet metal 2
12 174-8897 Spray tube 2
13 174-8898 Hose 26 in
14 174-8899 T-reducer 1
15 174-8900 Protection cap 4
16 174-8904 Spring 1
17 174-8905 Gear 1
18 174-8906 Circlip 1
19 174-8901 Center lock 1
20 174-8902 Self tapping screw 6
21 174-8903 Center lock retainer 1

Scrub Deck Assembly - Disk - Part 2

#PartDescription ReqNotesAvailability
1 999-1372 Bolt M10-1.5 x 25mm hex head stainless steel 2
2 174-8888 Washer 2
3 174-8483 Ejector 2
4 174-8484 Bellow 2
5 174-8485 Compression spring 2
6 174-8977 Slide bearing 2
7 174-9618 Retaining washer 2
8 174-8449 Tension band 96 in
9 174-8450 Tension band lock 1
10 274-5298 SEALING STRIP 1
11 999-1120 Nut M10-1.5 nylon insert lock stainless steel 3
12 274-1899 DEFLECTOR ROLLER 1
13 174-4192 Retainer 1
14 174-9617 Screw 1

Solution Tank Assembly

#PartDescription ReqNotesAvailability
1 174-8952 Solution tank lid 1
2 174-8953 Tank hinge 3
3 174-9630 Washer M9 conical spring with tooth 6
4 999-0784 Screw M8-1.25 x 16mm hex head stainless steel 6
5 999-1514 Screw M6-1 x 10mm button head socket stainless steel 5
6 174-8926 Hose support 1
7 274-6137 SOLUTION HOSE 1
8 174-3516 Hose clamp 1
9 174-8955 Hose barb elbow fitting 1
10 174-8956 O-ring 1
11 174-4162 Solution tank 1
12 174-8455 Drain hose assembly 1
13 174-8957 Hook 1
14 997-2000 Hose clamp 1
15 174-4163 Cross beam 1
16 174-8958 Edge protection (Sold by the foot) 28 in
17 174-8959 O-ring 1
18 999-9101 Screw M4-.7 x 10mm pan head stainless steel 2
19 174-8960 Drain hose cap 1
20 174-8961 Decal 1
21 374-2279 HOSE SUPPORT 1
22 999-0784 Screw M8-1.25 x 16mm hex head stainless steel 4
23 999-9097 Washer M8 flat stainless steel 4

Squeegee Assembly

#PartDescription ReqNotesAvailability
1 999-0495 Nut M5-.8 nylon insert lock zinc plated 2
2 174-8327 Lever 1
3 174-8938 Bushing 2
4 174-8341 Pressure pin 1
5 999-0740 Nut M5-.8 hex stainless steel 1
6 174-8338 Bolt M5 x 40mm eye stainless steel 1
7 174-8947 Screw M5-.8 x 30 hex head stainless steel 2
8 174-7105 Latch assembly 1 (includes 1-7)
9 174-8474 Front tension band 1
10 174-8475 Front tension band 1
11 174-7082 Squeegee blade urethane front 1
12 174-7132 Squeegee assembly 1
13 174-7083 Rear polyurethane blade 1
14 274-5840 REAR TENSION BAND 1
15 274-4151 REAR TENSION BAND 1

Squeegee Bracket and Wheel Assembly

#PartDescription ReqNotesAvailability
1 374-1549 HEXAGON SCREW 4
2 999-9097 Washer M8 flat stainless steel 12
3 999-0784 Screw M8-1.25 x 16mm hex head stainless steel 4
4 374-1931 Washer flat 8.3 x 22 x 1.00mm stainless steel 22
5 174-8933 Fixed caster 4
6 174-4176 Fixed castor 2 (includes 2-5)
7 999-0501 Bolt M8-1.25 x 25mm hex head full thread stainless steel 2
8 999-1267 Washer M8 flat zinc 4
9 174-9628 Bushing 2
10 174-8340 Guide wheel 2
11 174-4177 Bracket 1
12 174-8935 Hose (sold by the Meter) 12 in
13 174-8339 Star knob 2
14 174-8669 Washer M10.6 serrated tooth 2
15 174-8933 Fixed caster 2 (includes 2-5)

Squeegee Connection Assembly Part 1 - Before April 2008

#PartDescription ReqNotesAvailability
1 174-9642 Bolt M8-1.25 x 55mm carriage head 1
2 174-8999 Cable attach pivot 1
3 174-8992 Slide bearing 2
4 174-3503 Pipe 1
5 174-9649 Slide bearing bushing 2
6 174-9648 Cotter pin 1
7 999-9097 Washer M8 flat stainless steel 5
8 174-9000 Squeegee bracket 1
9 274-0001 BOLT 1
10 274-6198 SHEET METAL 1
11 999-9097 Washer M8 flat stainless steel 1
12 999-0496 Nut M8-1.25 nylon insert lock stainless steel 3
13 999-0501 Bolt M8-1.25 x 25mm hex head full thread stainless steel 2
14 174-8970 Bushing 2
15 174-8982 Edge protection 1

Squeegee Connection Assembly Part 1 - From April 2008

#PartDescription ReqNotesAvailability
1 174-9642 Bolt M8-1.25 x 55mm carriage head 1
2 174-8999 Cable attach pivot 1
3 174-8992 Slide bearing 2
4 N/A Not available 1 (pipe)
5 174-8974 Bushing 2
6 174-4153 Shaft 1
7 999-9097 Washer M8 flat stainless steel 3
8 174-3506 Squeegee bracket 1
9 N/A Not available 3 (pin)
10 174-4156 Bracket 1
11 999-9097 Washer M8 flat stainless steel 1
12 999-0496 Nut M8-1.25 nylon insert lock stainless steel 4
13 999-0784 Screw M8-1.25 x 16mm hex head stainless steel 2
14 374-2358 SLIDE BEARING BUSH 2
15 174-8982 Edge protection 2 in
16 174-3508 Bearing 2

Squeegee Connection Assembly Part 2 - Before April 2008

#PartDescription ReqNotesAvailability
1 174-9648 Cotter pin 1
2 999-9097 Washer M8 flat stainless steel 1
3 174-9649 Slide bearing bushing 2
4 174-9643 Bolt 1
5 174-9650 Control arm 1
6 174-4148 Bolt 1
7 174-9651 Sqeegee weldment 1
8 999-1551 Nut M8-1.25 hex jam zinc plated 2
9 999-0497 Nut M6-1 nylon insert lock stainless steel 2
10 999-1261 Washer M6 flat stainless steel 4
11 174-8926 Hose support 1
12 999-1312 Screw M6-1 x 20mm hex head stainless steel 2
13 174-9646 Threaded pin 1
14 999-9097 Washer M8 flat stainless steel 1
15 999-0496 Nut M8-1.25 nylon insert lock stainless steel 1
16 174-9647 Nut M6-1 wing 1
N/S 999-1308 Nut M6-1 hex stainless steel 1

Squeegee Connection Assembly Part 2 - From April 2008

#PartDescription ReqNotesAvailability
1 999-0496 Nut M8-1.25 nylon insert lock stainless steel 2
2 999-9097 Washer M8 flat stainless steel 2
3 174-8974 Bushing 2
4 N/A Not available 3 (threaded bolt)
5 174-9652 Control arm 1
6 174-3502 Control arm bracket 1
7 999-0497 Nut M6-1 nylon insert lock stainless steel 1
8 999-1261 Washer M6 flat stainless steel 2
9 174-8926 Hose support 1
10 999-1312 Screw M6-1 x 20mm hex head stainless steel 1

Squeegee Lift Handle Assembly

#PartDescription ReqNotesAvailability
1 174-8927 Handle 1
2 274-3328 Squeegee lift lever weldment 1
3 999-0497 Nut M6-1 nylon insert lock stainless steel 1
4 999-1261 Washer M6 flat stainless steel 1
5 174-8928 Slide bearing bushing 2
6 174-3510 Support plate 1
7 174-8929 Shaft 1
8 174-8930 Threaded switch mount plate 1
9 174-8931 Micro switch 1
10 999-1521 Washer M3 flat stainless steel 2
11 999-1897 Screw M3-.5 x 20mm hex head 2
12 174-3511 Squeegee lift assembly 1 (includes 1-11, 13)
13 999-1514 Screw M6-1 x 10mm button head socket stainless steel 4

Squeegee Lock Assembly

#PartDescription ReqNotesAvailability
0 174-4222 Suction cup lock 1 (includes 1-8)
1 174-9618 Retaining washer 2
2 174-4172 Bearing bush 1
3 274-5171 FOLDING PLATE 1
4 174-4173 Compression spring 1
5 174-4174 Pin 1
6 999-9092 Screw M8-1.25 x 20mm hex head stainless steel 1
7 174-9630 Washer M9 conical spring with tooth 1
8 174-4088 Spacer sleeve 1

Traction Drive Motor Assembly

#PartDescription ReqNotesAvailability
0 174-4117 Traction drive 1 (includes 1-13)
1 174-3522 Washer 2
2 N/A Not available 2 (gasket)
3 174-8916 Fitting key 2
4 N/A Not available 1 (gear box with shaft)
5 N/A Not available 1 (motor)
6 N/A Not available 1 (end cap)
7 N/A Not available 4 (carbon Brush)
8 174-3525 Bushing 2
9 174-3526 Nut 4
10 N/A Not available 1 (spring pin)
11 N/A Not available 1 (parking break)
12 N/A Not available 3 (plain washer)
13 N/A Not available 3 (screw)

Vacuum Motor Assembly

#PartDescription ReqNotesAvailability
0 174-3950 Vacuum motor assembly 1 (includes 1-21)
1 174-3533 Gasket 1
2 174-8949 Exhaust hose 1
3 174-1624 2 1/2 Hose clamp 1
4 174-8950 Connection 1
5 999-0497 Nut M6-1 nylon insert lock stainless steel 3
6 999-1261 Washer M6 flat stainless steel 8
7 174-8495 24V vacuum motor 1
8 174-9437 Carbon brush 4
9 174-8951 Isolator mount 3
10 999-0778 Screw M6-1 x 10mm hex head 3
14 997-2102 Cable tie 1
15 174-6185 Cable tie large 4
16 999-9097 Washer M8 flat stainless steel 3
17 999-0784 Screw M8-1.25 x 16mm hex head stainless steel 3
18 999-9116 Screw M6-1 x 12mm hex head stainless steel 2
19 174-3536 Cover 1
20 174-3537 Gasket 1
21 174-3538 Vacuum motor housing 1

Water Supply Assembly

#PartDescription ReqNotesAvailability
0 174-4118 Water supply 1 (includes 1-11)
1 174-3670 Water filter assembly 1 (includes 2-3)
2 N/A Not available 1 (filter cartridge) (complete with o-ring)
3 174-7081 Filter cap 1
4 174-1628 Hose clamp 4
5 174-9631 PVC hose (Sold by the Meter) 12 in
6 174-9635 Water filter bracket 1
7 999-9089 Washer M4 flat stainless steel 2
8 999-0955 Nut M4-.7 hex nylon lock 2
9 174-9631 PVC hose (Sold by the Meter) 19 in
10 274-1712 STRAIGHT SCREW CONNECTION 1
11 174-4135 Sealing band 1

Wiring Harness Assembly

#PartDescription ReqNotesAvailability
1 174-8985 Cover plate 1
2 999-1514 Screw M6-1 x 10mm button head socket stainless steel 7
3 174-8986 Bracket 1
4 174-8987 Pouch 1
5 999-9100 Washer M5 flat stainless steel 3
6 174-8988 Blind rivet 3
14 174-4184 Clamping plate 1
15 999-1261 Washer M6 flat stainless steel 2
16 999-9097 Washer M8 flat stainless steel 1
17 999-9092 Screw M8-1.25 x 20mm hex head stainless steel 1
18 997-2102 Cable tie 10
19 174-6185 Cable tie large 2
20 174-8989 Wiring retainer plate 1
21 174-4185 Distance plate 1
22 999-0781 Screw M6-1 x 45mm hex head 2
N/S 174-4179 W1 wiring harness 1
N/S 274-9527 WIRING HARNESS W2 1
N/S 374-3197 W3 wiring harness 1
N/S 174-4181 W9 wiring harness 1
N/S 274-9434 WIRING HARNESS W11- BATTERY PACK 1
N/S 174-6601 2 piece cable set 1
N/S 174-4183 Cable loom 1
N/S 174-4186 Cable loom 1