Parts List Complete for NILFISK CS 7000
 

- Commonly Asked For Parts - 272-9897
RefNbr Part Number Description Req Notes
01 172-9347 Filter (solution filter)
02 272-9981 Filter (Recovery lid)
03 372-1230 Solution filter kit (High pressure pump)
04 272-3270 Air cleaner
05 272-3271 Primary element (For 272-3270)
06 372-1231 Oil filter cartridge
07 372-1232 Rectangular synthetic filter
08 372-1145 Squeegee blade kit gum rubber (red)
09 572-1606 BLADE KIT-SQGEE-GUM
10 572-1607 BLADE KIT-SQGEE-PU
11 272-3779 Mold-on wheel 16.2 x 4
12 372-2979 Drive wheel

- Pad Holders - 275-9029
RefNbr Part Number Description Req Notes
1 991-2214 Center-Lok II pad holder - left hand thread (red)
2a 991-2201 Center-Lok II pad holder - right hand thread (black) (Pad driver side female, Floor side male)
2b 991-8577 Pad retainer (Pad driver side male, Floor side female)
3a 991-2202 Big mouth pad holder set (blue) (includes 3 screws)
3b 991-2205 Deep lock ring and pad grip ring
4 991-2203 Big mouth pad holder male thread portion
5 991-2206 Center-Lok 3 pad holder (includes 3 screws)
6 996-0372 Big mouth pad holder (left hand thread)
7 N/A Not available
8 991-2209 Split retainer - pad holder ring (OBSOLETE)
9 N/A Not available (replaced by #3 991-2202)
10 991-2211 Center lock pad holding cup (male) (yellow) (OBSOLETE)

Chassis System Assembly - 372-0045
RefNbr Part Number Description Req Notes
1 N/A Not available 3 (screw) (qty 2 for LPG and diesel) (only available in KIT2 and KIT4)
2 999-0114 Washer 1/2 SAE flat 4 (battery model) (included in KIT4 and KIT5)
3 999-9004 Washer 5/16 SAE flat stainless steel 6 (included in KIT2, KIT3 and kIT4)
4 999-0333 Screw 10-24 x 1/2 pan head phillips stainless steel 1 (battery model) (included in KIT4)
5 999-0120 Washer 3/8 SAE flat 10 (qty 6 for LPG and diesel) (included in KIT2 and KIT4)
6 999-0123 Washer 1/4 SAE flat zinc plated 4 (qty 8 for LPG and diesel) (included in KIT2, KIT3, and KIT4)
7 N/A Not available 4 (screw) (qty 2 for LPG and diesel) (only available in KIT2, KIT3 and KIT4)
8 N/A Not available 1 (screw) (only available in KIT4)
9 999-0294 Nut 1/4-20 hex nylon lock type NE stainless steel 2 (included in KIT2 and KIT4)
10 999-0570 Screw 10-24 x 1 1/4 pan head phillips stainless steel 1 (included in KIT2 and KIT4)
11 N/A Not available 8 (nut) (qty 6 for LPG and diesel) (only available in KIT2, KIT3 and KIT4)
12 N/A Not available 2 (nut) (only available in KIT2 and KIT4)
13 N/A Not available 3 (nut) (battery model) (only available in KIT4)
14 N/A Not available 2 (nut) (only available in KIT2, KIT3 and KIT4)
15 N/A Not available 1 (nut) (battery model) (only available in KIT4)
16 999-1343 Screw 5/16-18 x 5/8 hex head stainless steel 6 (included in KIT2 and KIT4)
17 N/A Not available 10 (screw) (qty 6 LPG and diesel) (only available in KIT2, KIT3 and KIT4)
18 999-1232 Screw 5/16-18 x 3/4 hex head stainless steel 2 (included in KIT2, KIT3 and KIT4)
19 999-0822 Screw 1/4-20 x 7/8 hex head plain finish 2 (included in KIT2 and KIT4)
20 N/A Not available 3 (screw) (qty 1 LPG and diesel) (only available in KIT2, KIT4 and KIT5)
21 999-1006 Screw 3/8-16 x 1 3/4 hex head stainless steel 2 (battery model) (included in KIT4 and KIT5)
22 N/A Not available 3 (screw) (battery model) (only available in KIT4 and KIT5)
23 N/A Not available 10 (washer) (only available in KIT1, KIT2 and KIT4)
24 999-1129 Screw 1/4-20 x 1/2 pan head phillips thread rolling zinc 10 (included in KIT 1, KIT2 and KIT4)
25 999-0181 Nut 1/4-20 hex jam plain finish 1 (included in KIT3)
26 272-7595 Tank stop bracket 2
27 172-2631 Bushing 1
28 472-5743 ROLLER ASSEMBLY 6 (battery model)
29 272-8850 Proximity sensor 1 (battery model)
30 272-0420 Gas spring 1
31 N/A Not available 1 (leg leveler) (only available in KIT3)
32 472-8953 SHIELDED PULLEY 1
33 N/A Not available 1 (chassis weldment)
34 372-2706 Front engine cover assembly 1
35 N/A Not available 1 (roller bracket) (battery model) (only available in KIT5)
36 372-1398 Engine cover 1
37 372-2707 Right hand door assembly 1
38 372-1400 Support panel 1
39a 372-1416 Plate assembly 1 (battery model) (includes 39b-39l)
39b 172-9507 Leveler 2 (battery model)
39c 999-1862 Washer #10 flat SAE stainless steel 1 (battery model)
39d 999-0705 Screw 10-24 x 3/4 pan head phillips stainless steel 1 (battery model)
39e 472-3477 NUT WING 1 1/2-13 2 (battery model)
39f 181-0223 Screw socket head 1 (battery model)
39g 172-8283 Spring .38 x 2 1 (battery model)
39h 472-5770 BEARING FL .375X.250X.188 1 (battery model)
39i 172-8164 Bushing 1 (battery model)
39j 472-8733 WASHER TEFLON .21X.88X.045 1 (battery model)
39k 372-1417 Plate 1 (battery model)
39l 372-1418 Latch 1 (battery model)
40 372-1419 Bracket 1 (battery model)
41 N/A Not available 1 (front battery guide) (battery model) (only available in KIT5)
42 N/A Not available 1 (battery guide weldment) (battery model) (only available in KIT5)
43 372-1401 Left hand cover 1
44 372-1402 Lower cover 1
45 372-1404 Pull rod assembly 1
46 372-1405 Bushing 1
47 372-1406 Reservoir guard 1
48 N/A Not available 1 (dust shield) (only available in KIT1)
49 N/A Not available 2 (bushing) (battery model) (only available in KIT5)
50 N/A Not available 1 (battery stop weldment) (battery model) (only available in KIT5)
51 372-1420 Bracket 1 (battery model)
52 N/A Not available 1 (bracket) (battery model) (only available in KIT5)
53 372-2708 Bracket (OBSOLETE) 1
54 472-7756 HANGER-SIDE PANEL 1
55 372-1408 Nut plate 1
56a 372-1421 Cover plate assembly 1 (battery model)
56b 172-9788 Door latch 1 (LPG and diesel)
57 372-1422 Retainer 1 (battery model)
58 N/A Not available 1 (strike latch) (only availabele in KIT3)
59 N/A Not available 1 (bracket) (only available in KIT3)
60 N/A Not available 4 (carriage bolt) (only available in KIT5)
61 372-1411 Foam insulation 1 (LPG and diesel)
62 372-1412 Foam insulation 1 (LPG and diesel)
N/S N/A Not available 2 (screw) (LPG and diesel) (only available in KIT2)
N/S N/A Not available 2 (washer) (LPG and diesel) (only available in KIT2)
N/S 372-2709 Panel stop weldment (OBSOOLETE) 1 (LPG and diesel)
N/S 372-1409 Bracket 1 (LPG and diesel)
N/S 372-1410 Latch 1 (LPG and diesel)
KIT1 372-1414 Dust shield 1 (includes 23-24, 48)
KIT2 372-2710 Chassis hardware kit 1 (includes 1, 3, 5-7, 9-12, 14, 16-20, 23-24)
KIT3 372-2711 Right hand door latch kit (OBSOLETE) 1 (includes 3, 6-7, 14, 18, 31, 58-59)
KIT4 372-1414 Dust shield 1 (includes 1-24)
KIT5 372-2711 Right hand door latch kit (OBSOLETE) 1 (includes 2, 11, 17, 20-22, 35, 41-42, 49-50, 52, 60)

Front Engine Cover Assembly - 372-0046
RefNbr Part Number Description Req Notes
0 372-2706 Front engine cover assembly 1 (includes 1-14)
1 999-1343 Screw 5/16-18 x 5/8 hex head stainless steel 2 (included in KIT1)
2 999-1232 Screw 5/16-18 x 3/4 hex head stainless steel 4 (included in KIT1)
3 999-0822 Screw 1/4-20 x 7/8 hex head plain finish 4 (included in KIT1)
4 N/A Not available 4 (washer) (only available in KIT1)
5 N/A Not available 2 (washer) (only available in KIT1)
6 372-1424 Engine cover 1
7 N/A Not available 1 (right hand hinge weldment) (only available in KIT1)
8 N/A Not available 1 (left hand hinge weldment) (only available in KIT1)
9 N/A Not available 1 (bracket) (only available in KIT1)
10 N/A Not available 1 (bracket) (only available in KIT1)
11 N/A Not available 1 (bracket) (only available in KIT1)
12 N/A Not available 1 (bracket) (only available in KIT1)
13 N/A Not available 1 (bracket) (only available in KIT1)
14 N/A Not available 1 (bracket) (only available in KIT1)
KIT1 472-7772 FRONT ENGINE COVER HINGE KIT 1 (includes 1-5, 7-14)

Engine Cover Assembly - 372-0047
RefNbr Part Number Description Req Notes
0 372-1398 Engine cover 1
1 999-1862 Washer #10 flat SAE stainless steel 7 (included in KIT1)
2 999-0123 Washer 1/4 SAE flat zinc plated 2 (included in KIT1)
3 999-0567 Screw 1/4-20 x 5/8 pan head phillips stainless steel 2 (included in KIT2)
4 999-1232 Screw 5/16-18 x 3/4 hex head stainless steel 2 (included in KIT2)
5 N/A Not available 7 (screw) (only available in KIT1)
6 N/A Not available 2 (screw) (only available in KIT1)
7 N/A Not available 2 (bushing) (only available in KIT1)
8 372-1427 Rear engine cover 1
9 N/A Not available 1 (bracket) (only available in KIT2)
10 N/A Not available 1 (latch strike weldment) (only available in KIT2)
11 N/A Not available 1 (shield) (only available in KIT1)
12 N/A Not available 1 (plate seal) (only available in KIT1)
13 N/A Not available 1 (shield) (only available in KIT1)
14 N/A Not available 1 (bulb seal) (only available in KIT1)
KIT1 372-1425 Seal kit 1 (includes 1-2, 5-7, 11-14)
KIT2 372-1426 Latch strike kit 1 (includes 3-4, 9-10)

Right Hand Door Assembly - 372-0048
RefNbr Part Number Description Req Notes
0 372-2707 Right hand door assembly 1 (includes 1-13)
1 999-0024 Washer 5/16 flat stainless steel 2
2 999-0123 Washer 1/4 SAE flat zinc plated 8 (included in KIT1)
3 N/A Not available 8 (screw) (included in KIT1)
4 999-1232 Screw 5/16-18 x 3/4 hex head stainless steel 2
5 N/A Not available 10 (screw) (included in KIT1)
6 999-1833 Screw 10-14 x 3/8 pan head phillips stainless steel 6
7 N/A Not available 2 (upper hinge weldment) (only available in KIT1)
8 N/A Not available 2 (lower hinge weldment) (only available in KIT1)
9 372-2713 Right hand door 1
10 372-2714 Side door stiffener 1
11 372-1429 Right hand grille 1
12 372-2715 Latch bracket 1
13 372-2716 Door latch 1
KIT1 372-1430 Right hand hinge kit 1 (includes 2-3, 5, 7-8)

Left Cover Assembly - 372-0049
RefNbr Part Number Description Req Notes
0 372-1401 Left hand cover 1
1 999-0567 Screw 1/4-20 x 5/8 pan head phillips stainless steel 8
2 999-0152 Nut 1/4-20 nylon insert lock zinc plated 8
3 372-1431 Left hand cover 1
4 372-1432 Grille 1

Pull Rod Assembly - 372-0050
RefNbr Part Number Description Req Notes
0 372-1404 Pull rod assembly 1 (includes 1-23)
1 999-1260 Screw 1/4-20 x 1 1/2 hex cap stainless steel 3 (included in KIT1 and KIT2)
2 999-9004 Washer 5/16 SAE flat stainless steel 2 (included in KIT1)
3 999-0123 Washer 1/4 SAE flat zinc plated 8 (included in KIT1 and KIT2)
4 N/A Not available 3 (screw) (only available in KIT2)
5 N/A Not available 1 (nut) (only available in KIT1)
6 999-1231 Screw 10-24 x 5/8 hex head stainless steel 1 (included in KIT1)
7 N/A Not available 6 (nut) (only available in KIT1 and KIT2)
8 999-1343 Screw 5/16-18 x 5/8 hex head stainless steel 2 (included in KIT1)
9 999-1948 Nut 1/4-20 wing lock 1 (included in KIT2)
10 999-1866 Screw 10-24 x 3/8 pan head phillips nylon stainless steel 1 (included in KIT1)
11 N/A Not available 3 (bushing) (only available in KIT2)
12 N/A Not available 1 (bearing) (only available in KIT2)
13 472-6058 LATCH LH 1
14 N/A Not available 1 (latch bracket) (only available in KIT1)
15 N/A Not available 1 (pin) (only available in KIT1)
16 372-1436 Pull rod 1
17 N/A Not available 1 (yoke) (only available in KIT2)
18 N/A Not available 1 (pivot weldment) (only available in KIT2)
19 N/A Not available 1 (pull rod bracket) (only available in KIT1)
20 N/A Not available 1 (bushing) (only available in KIT2)
21 N/A Not available 1 (pull rod retainer) (only available in KIT1)
22 N/A Not available 1 (cable assembly) (only available in KIT2)
23 999-1968 Nut 10-24 wing stainless steel 1 (included in KIT1)
KIT1 372-1433 Engine cover latch kit 1 (includes 1-3, 5-8, 10, 13-15, 19, 21, 23)
KIT2 372-1434 Pull rod pivot kit 1 (includes 1, 3-4, 7, 9, 11-12, 17-18, 20, 22)

Control System Assembly - 372-0051
RefNbr Part Number Description Req Notes
1 N/A Not available 2 (screw) (only available in KIT2)
2 999-1532 Screw 1/4-20 x 1/2 hex head stainless steel 4 (included in KIT2)
3 999-0123 Washer 1/4 SAE flat zinc plated 4 (included in KIT2)
4 999-0412 Washer #8 SAE flat 2 (included in KIT2)
5 999-0005 Screw 5/16-18 x 7/8 socket head 4 (included in KIT2)
6 999-0456 Screw 1/4-20 x 3/4 pan head phillips stainless steel 3 (included in KIT1)
7 N/A Not available 2 (nut) (only available in KIT2)
8 999-9006 Screw 5/16-18 x 3/4 pan head phillips stainless steel 4 (included in KIT2)
9 N/A Not available 1 (screw) (only available in KIT2)
10 N/A Not available 2 (screw) (only available in KIT2)
11 N/A Not available 1 (washer) (only available in KIT2)
12 999-1104 Screw 10-24 x 3/4 pan head phillips thread rolling zinc 4 (included in KIT2)
13 999-1129 Screw 1/4-20 x 1/2 pan head phillips thread rolling zinc 4 (included in KIT2)
14 272-8850 Proximity sensor 2
15 372-1439 Steering controller 1
16 172-9147 Terminal insulator 5
17 372-2718 Tilt steering assembly (OBSOLETE) 1
18 N/A Not available 1 (brake linkage assembly)
19 372-1440 Steering cam 1
20 372-1441 Spacer 2
21 372-3099 Sensor mounting bracket 1
22 372-1442 Splash shield 1
23 N/A Not available 1 (foot pedal assembly) (only available in KIT1)
24 472-7286 MOTOR STEERING 36V 1
25 372-2720 Sensor mounting bracket (OBSOLETE) 1
KIT1 372-1437 Foot pedal kit 1 (includes 6 and 23)
KIT2 372-1438 Control system hardware kit 1 (includes 1-5, 7-13)

Steering System Assembly - 372-0052
RefNbr Part Number Description Req Notes
1 N/A Not available 3 (screw) (only available in KIT1 and KIT4)
2 999-0114 Washer 1/2 SAE flat 1 (included in KIT1)
3 999-9004 Washer 5/16 SAE flat stainless steel 5 (included in KIT4)
4 999-0120 Washer 3/8 SAE flat 2 (included in KIT2)
5 999-0567 Screw 1/4-20 x 5/8 pan head phillips stainless steel 3 (included in KIT3)
6 N/A Not available 1 (screw) (only available in KIT4)
7 999-0332 Screw 10-24 x 5/8 pan head phillips stainless steel 4 (included in KIT3)
8 999-0031 Bolt 5/16-18 x 1 hex head grade 5 zinc plated 3 (included in KIT4)
9 999-0211 Nut 5/16-18 hex nylon insert lock zinc plated 4 (included in KIT3 and KIT4)
10 999-0294 Nut 1/4-20 hex nylon lock type NE stainless steel 3 (included in KIT4)
11 N/A Not available 4 (nut) (only available in KIT3)
12 N/A Not available 5 (nut) (only available in KIT1 and KIT3)
13 N/A Not available 1 (nut) (only available in KIT1)
14 N/A Not available 2 (screw) (only available in KIT2)
15 N/A Not available 1 (key) (only available in KIT1)
16 999-1131 Screw 8-32 x 3/8 pan head phillips thread rolling SS 2 (included in KIT3)
17 999-1058 Screw 1/4-20 x 3/4 pan head thread rolling phillips 4 (included in KIT5)
18 N/A Not available 1 (grommet) (only available in KIT2)
19 N/A Not available 1 (bushing) (only available in KIT3)
20 N/A Not available 4 (flange bearing) (only available in KIT4)
21 N/A Not available 1 (steering column ratchet) (only available in KIT3)
22 N/A Not available 5 (bushing) (only available in KIT4)
23 N/A Not available 1 (extension spring) (only available in KIT4)
24 N/A Not available 1 (tilt-steering weldment) (only available in KIT3)
25 N/A Not available 1 (steering boot) (only available in KIT5)
26 N/A Not available 1 (boot holder plate) (only available in KIT5)
27 N/A Not available 1 (steering mount weldment) (only available in KIT4)
28 N/A Not available 1 (tilt lever weldment) (only available in KIT4)
29 N/A Not available 1 (steering clamp plate) (only available in KIT2)
30 N/A Not available 1 (steering shaft) (only available in KIT1)
31 372-1443 Torque feedback device (OBSOLETE) 1
32 272-8887 Steering wheel 1
33 372-1444 Universal joint 1
34 N/A Not available 4 (spacer) (only available in KIT4)
KIT1 372-1445 Steering shaft kit 1 (includes 1-2, 12-13, 15, 30)
KIT2 372-1446 Steering clamp plate kit 1 (includes 4, 14, 18, 29)
KIT3 372-1447 Steering column kit 1 (includes 5, 7, 9, 11-12, 16, 19, 21, 24)
KIT4 372-1448 Steering housing kit 1 (includes 1, 3, 6, 8-10, 20, 22-23, 27-28)
KIT5 372-1449 Steering boot kit 1 (includes 17, 25-26, 34)

Brake Linkage Assembly - 372-0053
RefNbr Part Number Description Req Notes
1 N/A Not available 1 (screw) (only available in KIT2)
2 N/A Not available 2 (screw) (only available in KIT2)
3 999-0333 Screw 10-24 x 1/2 pan head phillips stainless steel 1 (included in KIT2)
4 999-0120 Washer 3/8 SAE flat 2 (included in KIT1 and KIT2)
5 999-0123 Washer 1/4 SAE flat zinc plated 8 (included in KIT2)
6 999-1006 Screw 3/8-16 x 1 3/4 hex head stainless steel 1 (included in KIT1)
7 999-0294 Nut 1/4-20 hex nylon lock type NE stainless steel 4 (included in KIT2)
8 999-1136 Screw 1/4-20 x 7/8 pan head phillips stainless steel 2 (included in KIT2)
9 N/A Not available 1 (nut) (only available in KIT2)
10 N/A Not available 2 (nut) (only available in KIT1 and KIT2)
11 999-0822 Screw 1/4-20 x 7/8 hex head plain finish 4 (included in KIT2)
12 999-0273 Screw 1/4-20 x 1/2 hex washer head thread rolling zinc 2 (included in KIT1)
13 999-0169 Nut 3/8-24 hex jam plain finish 1 (included in KIT2)
14 N/A Not available 2 (nut) (only available in KIT2)
15 472-4292 YOKE CLEVIS 2
16 272-7653 Brake lock catch 1
17 272-8850 Proximity sensor 1
18 372-1450 Weldment brake bar 1
19 372-1451 Brake rod 1
20 372-1452 Brake rod 2
21 372-1453 Pivot brake 4
22 372-1454 Switch mount bracket 1
23a N/A Not available 1 (brake pedal assembly) (includes 6, 23b-23m) (only available in KIT1)
23b 999-0114 Washer 1/2 SAE flat 2 (included in KIT1)
23c 999-9004 Washer 5/16 SAE flat stainless steel 2 (included in KIT1)
23d 999-0031 Bolt 5/16-18 x 1 hex head grade 5 zinc plated 1 (included in KIT1)
23e N/A Not available 1 (nut) (only available in KIT1)
23f N/A Not available 1 (nut) (only available in KIT1)
23g N/A Not available 1 (screw) (only available in KIT1)
23h N/A Not available 1 (bushing) (only available in KIT1)
23i N/A Not available 2 (bearing) (only available in KIT1)
23j N/A Not available 1 (extension spring) (only available in KIT1)
23k N/A Not available 1 (bushing) (only available in KIT1)
23l N/A Not available 1 (brake pedal weldment) (only available in KIT1)
23m N/A Not available 1 (park brake pedal) (only available in KIT1)
24 372-1455 Right hand rod end 1
25 372-1456 Left hand rod end 1
26 272-5619 Female rod end 2
KIT1 372-1457 Brake pedal kit 1 (includes 4, 6, 10, 12, 16, 23a-23m)
KIT2 372-1458 Brake linkage hardware kit 1 (includes 1-5, 7-11, 13-14)

Decal System Assembly - 372-0054
RefNbr Part Number Description Req Notes
1 N/A Not available 1 (caution decal) (only available in KIT1)
2 N/A Not available 1 (LPG decal) (only available in KIT1)
3 N/A Not available 1 (broom warning decal) (only available in KIT1)
4 N/A Not available 1 (tip over warning decal) (only available in KIT1)
5 N/A Not available 1 (hot warning decal) (LPG and diesel) (only available in KIT1)
6 N/A Not available 1 (advance decal) (only available in KIT1)
7 N/A Not available 1 (diesel fuel decal) (only available in KIT1)
8 N/A Not available 1 (low sulfur diesel decal) (only available in KIT1)
9 N/A Not available 1 (exhaust decal) (LPG and diesel) (only available in KIT1)
10a N/A Not available 2 (CS7000 decal) (only available in KIT1)
10b N/A Not available 2 (CS7000 Ecoflex decal) (only available in KIT1)
11 N/A Not available 1 (circuit breaker decal) (only available in KIT1)
12 N/A Not available 1 (contactor location decal) (only available in KIT1)
13 N/A Not available 1 (battery wiring decal) (battery model) (only available in KIT1)
14 N/A Not available 1 (swing out tank decal) (diesel model) (only available in KIT1)
15 N/A Not available 1 (hopper safety support decal) (only available in KIT1)
16 N/A Not available 1 (battery wiring decal) (only available in KIT1)
17 N/A Not available 1 (belt removal tool decal) (only available in KIT1)
18a 372-1460 Hybrid embossed decal 2 (LPG and diesel) (included in KIT1)
18b 372-1461 E power embossed decal 2 (battery model) (included in KIT1)
19 N/A Not available 1 (filter shaker hanger decal) (only available in KIT1)
20 N/A Not available 1 (disconnect power decal) (only available in KIT1)
21 N/A Not available 1 (hopper warning decal) (only available in KIT1)
22 N/A Not available 1 (hydraulic warning decal) (only available in KIT1)
KIT1 372-2721 Advance decal kit 1 (includes 1-22)

Dust Control System Assembly - 372-0055
RefNbr Part Number Description Req Notes
1 999-1032 Screw 1/4-20 x 5/8 hex head stainless steel 6 (included in KIT1)
2 999-0123 Washer 1/4 SAE flat zinc plated 6 (included in KIT1)
3 999-0211 Nut 5/16-18 hex nylon insert lock zinc plated 4 (included in KIT2 and KIT3)
4 N/A Not available 4 (screw) (only available in KIT2)
5 999-9004 Washer 5/16 SAE flat stainless steel 4 (included in KIT2)
6 N/A Not available 2 (screw) (only available in KIT2)
7 N/A Not available 2 (washer) (only available in KIT3)
8 172-4099 Nut 5/16-18 thumb 2
9a N/A Not available 1 (impeller assembly) (includes 9b-9k) (only available in KIT1)
9b 472-2563 MOTOR VACUUM 36V 1 (included in KIT1)
9c N/A Not available 1 (vacuum support) (only available in KIT1)
9d N/A Not available 1 (vacuum plate) (only available in KIT1)
9e N/A Not available 3 (spacer) (only available in KIT1)
9f 472-2626 GASKET 1 (included in KIT1)
9g N/A Not available 6 (nut) (only available in KIT1)
9h 999-1329 Screw M6-1 x 100mm hex head 3 (included in KIT1)
9i 999-0273 Screw 1/4-20 x 1/2 hex washer head thread rolling zinc 4 (included in KIT1)
9j N/A Not available 1 (cable tie) (only available in KIT1)
9k N/A Not available 1 (protection grate) (only available in KIT1)
10a 372-1462 Filter shaker assembly 1 (includes 10b-10m)
10b 999-0024 Washer 5/16 flat stainless steel 4 (included in KIT4 and KIT5)
10c 999-1223 Screw M12-1.75 x 25mm hex head stainless steel 2 (included in KIT4)
10d N/A Not available 4 (nut) (only available in KIT5)
10e N/A Not available 2 (washer) (only available in KIT5)
10f N/A Not available 1 (cable tie) (only available in KIT5)
10g N/A Not available 1 (filter shaker weldment) (only available in KIT5)
10h N/A Not available 2 (isolator) (only available in KIT5)
10i N/A Not available 1 (motor shaker clamp) (only available in KIT4)
10j N/A Not available 2 (washer) (only available in KIT5)
10k N/A Not available 1 (filter clamp weldment) (only available in KIT5)
10l N/A Not available 1 (filter clamp weldment) (only available in KIT5)
10m N/A Not available 1 (36V filter shaker motor) (only available in KIT4)
11 372-1463 Threaded rod 2
12 372-1232 Rectangular synthetic filter 1
13 N/A Not available 2 (filter tie down bracket) (only available in KIT2)
KIT1 372-1464 Impeller kit 1 (includes 1-2, 9a-9k)
KIT2 372-1465 Filter tie down bracket kit 1 (includes 3-6, 13)
KIT3 372-1466 Dust control system hardware kit 1 (includes 3 and 7)
KIT4 372-1467 Shaker motor kit 1 (includes 10b-10c, 10i, 10m)
KIT5 372-1468 Filter shaker kit 1 (includes 10b, 10d-10h, 10j-10l)

Ecoflex TM Assembly - 372-0056
RefNbr Part Number Description Req Notes
0 372-2722 Onboard chemical assembly 1 (includes 1-30)
1 999-1862 Washer #10 flat SAE stainless steel 4 (included in KIT2)
2 999-0571 Screw 10-24 x 3/8 pan head phillips stainless steel 2 (included in KIT2)
3 999-0123 Washer 1/4 SAE flat zinc plated 4 (included in KIT2)
4 999-0456 Screw 1/4-20 x 3/4 pan head phillips stainless steel 2 (included in KIT2)
5 N/A Not available 4 (nut) (only available in KIT2)
6 999-1477 Screw 10-24 x 1 1/4 hex head stainless steel 4 (included in KIT2)
7 N/A Not available 1 (bushing) (only available in KIT2)
8 N/A Not available 2 (screw) (only available in KIT2)
9 N/A Not available 1 (chemical ration decal) (only available in KIT2)
11 N/A Not available 2 (detergent pump) (only available in KIT1)
12 N/A Not available 2 (hose clamp) (only available in KIT3)
13 N/A Not available 1 (elbow) (only available in KIT3)
14 N/A Not available 1 (chemical resistant hose) (only available in KIT1)
15 N/A Not available 2 (raw cap) (only available in KIT4)
16 N/A Not available 1 (dry break cap) (only available in KIT4)
17 N/A Not available 1 (chemical resistant hose) (only available in KIT1)
18 N/A Not available 1 (cap) (only available in KIT4)
19 N/A Not available 1 (spiral hose) (only available in KIT3)
20 N/A Not available 2 (y barb fitting) (only available in KIT1)
21 N/A Not available 4 (chemical resistant hose) (only available in KIT1)
22 N/A Not available 2 (dry break insert) (only available in KIT4)
23 272-5716 Solution control pump 1
24 N/A Not available 1 (pump mount weldment) (only available in KIT2)
25 N/A Not available 1 (cover weldment) (only available in KIT2)
26 N/A Not available 1 (pump support weldment) (only available in KIT2)
27 N/A Not available 1 (coupling) (only available in KIT3)
28 N/A Not available 2 (chemical bottle assembly) (only available in KIT4)
29 N/A Not available 1 (elbow) (only available in KIT3)
30 N/A Not available 1 (tee) (only available in KIT3)
KIT1 372-1469 Detergent pump kit 1 (includes 11, 14, 17, 20-21)
KIT2 372-1470 Bracket hardware kit 1 (includes 1-9, 24-26)
KIT3 372-1471 Hose fitting kit 1 (includes 12-13, 19, 27, 29-30)
KIT4 372-1472 Chemical bottle kit 1 (includes 15-16, 18, 22, 28)

Electrical System Assembly - 372-0057
RefNbr Part Number Description Req Notes
1 999-1260 Screw 1/4-20 x 1 1/2 hex cap stainless steel 2 (included in KIT1, KIT2 and KIT3)
2 999-1032 Screw 1/4-20 x 5/8 hex head stainless steel 2 (included in KIT1, KIT2 and KIT3)
3 999-0603 Nut 1/4-20 wing stainless steel 2 (LPG and diesel) (included in KIT2 and KIT3)
4 N/A Not available 1 (screw) (LPG and diesel) (included in KIT2 and KIT3)
5 999-0123 Washer 1/4 SAE flat zinc plated 7 (qty 3 for battery model) (included in KIT1, KIT2 and KIT3)
6 999-0522 Screw 1/4-20 x 1/2 pan head phillips stainless steel 4 (included in KIT1, KIT2 and KIT3)
7 N/A Not available 4 (screw) (only available in KIT1, KIT2 and KIT3)
8 999-1531 Screw 3/8-16 x 1 hex washer head zinc plated 2 (LPG and diesel) (included in KIT2 and KIT3)
9 999-0211 Nut 5/16-18 hex nylon insert lock zinc plated 1 (included in KIT1, KIT2 and KIT3)
10 999-0294 Nut 1/4-20 hex nylon lock type NE stainless steel 1 (LPG and diesel) (included in KIT2 and KIT3)
11 N/A Not available 4 (nut) (only available in KIT1, KIT2 and KIT3)
12 N/A Not available 2 (nut) (only available in KIT1, KIT2 and KIT3)
13 999-9116 Screw M6-1 x 12mm hex head stainless steel 5 (included in KIT1, KIT2 and KIT3)
14 N/A Not available 3 (screw) (only available in KIT1, KIT2 and KIT3)
15 999-0273 Screw 1/4-20 x 1/2 hex washer head thread rolling zinc 3 (included in KIT1, KIT2 and KIT3)
16 999-1129 Screw 1/4-20 x 1/2 pan head phillips thread rolling zinc 1 (included in KIT1, KIT2 and KIT3)
17 N/A Not available 5 (washer) (only available in KIT1, KIT2 and KIT3)
18 999-1058 Screw 1/4-20 x 3/4 pan head thread rolling phillips 4 (included in KIT1, KIT2 and KIT3)
19 N/A Not available 2 (washer) (LPG and diesel) (only available in KIT2 and KIT3)
20 272-7714 Key switch assembly 1
21 162-6022 12V 102Ah gel battery (SNSR) 3 (LPG and diesel) (OEM)
22 272-9750 Fuse block 2
23 472-5774 FUSE 400 AMP 1
25 472-7303 BATTERY-12V 45AH WET 1 (diesel model)
26 172-9233 Emergency stop button 1
28 172-8836 150amp fuse 1
29 472-8620 WIRE ROPE ASSY 1 (LPG and diesel)
30 172-9432 36V horn 1
32 372-1509 Edge trim 1 (LPG and diesel)
33 372-1508 Traction controller kit 1
36 372-1475 Main power cable assembly 1
40 372-2723 User interface panel assembly (OBSOLETE) 1
41 N/A Not available 1 (circuit breaker panel assembly)
42 372-1480 Connector mount bracket 1
43 372-1482 Control board kit 1
44 372-1484 Control mount panel 1
45 372-1485 Battery box weldment 1 (LPG and diesel)
46 372-1486 Battery cover 1 (LPG and diesel)
47 N/A Not available 1 (contactor panel assembly)
61 372-1499 Fuse bar 1
62 372-1500 Cover 1
63 372-2724 Strap (OBSOLETE) 1
64 999-1152 Screw 10-24 x 3/8 pan head phillips thread rolling zinc 2 (diesel model) (included in KIT3)
65 272-7725 12V 75amp relay 1 (diesel model)
66 372-1502 40amp circuit breaker (OBSOLETE) 1 (diesel model)
67 372-1503 Disconnect bar 1 (diesel model)
68 999-0523 Screw 1/4-20 x 1 1/2 pan head phillips stainless steel 2 (diesel model) (included in KIT2 and KIT3)
N/S 172-0223 Battery cable boot 6
N/S 172-8828 Battery cable 2
N/S 172-8964 Terminal insulator 8
N/S 372-1474 Main harness 1
N/S 372-2725 Hopper harness (OBSOLETE) 1
N/S 372-1477 Alternator cable assembly 1
N/S 372-1478 Starter battery cable assembly 1
N/S 372-1479 Vacuum harness 1
N/S 372-1487 Engine interface harness 1
N/S 372-1489 13 3/4 inch u 1 awg cable 1
N/S 372-1490 16 inch v 1 awg cable 1
N/S 372-1491 19 inch w 1 awg cable 1
N/S 372-1492 52 1/4 inch 1 awg cable 1
N/S 372-1493 7 inch 4 awg cable 1
N/S 372-1494 46 1/2 inch 1 awg cable 1
N/S 372-2726 Cable 1 awg x 31.25 (OBSOLETE) 1
N/S 372-2727 Cable 1 awg x 46.75 (OBSOLETE) 1
N/S 372-1495 7 3/4 inch 4 awg cable 1
N/S 372-1496 9 inch 6 awg cable 1
N/S 372-1497 29 1/4 inch 1 awg cable 1
N/S 372-1498 26 1/2 inch 1 awg cable 1
N/S 372-2728 Glow plug harness (OBSOLETE) 1 (diesel model)
KIT1 372-1505 Electric system battery hardware kit 1 (includes 1-2, 5-7, 9, 11-18)
KIT2 372-1506 Electric system LPG hardware kit 1 (includes 1-19, 68)
KIT3 372-1507 Electric system diesel hardware kit 1 (includes 1-19, 64, 68)

Circuit Breaker Panel Assembly - 372-0058
RefNbr Part Number Description Req Notes
1 999-0332 Screw 10-24 x 5/8 pan head phillips stainless steel 4
2 991-1628 5amp circuit breaker 1
3 272-9755 15amp circuit breaker 1
4 272-7727 20amp circuit breaker 1
5 272-9374 10amp circuit breaker 1
6 372-1510 Circuit breaker panel 1
7 272-6708 25amp circuit breaker 1
8 372-1511 Panel gasket 1
9 272-6708 25amp circuit breaker 1
10 272-9755 15amp circuit breaker 1
11 272-6708 25amp circuit breaker 1
12 272-6708 25amp circuit breaker 1
13 272-6708 25amp circuit breaker 1

Contactor Panel Assembly - 372-0059
RefNbr Part Number Description Req Notes
1 172-2805 36V contactor 1
2 172-9261 P clamp 2
3 172-1779 36V relay SPST 1
4 999-1032 Screw 1/4-20 x 5/8 hex head stainless steel 4
5 999-0016 Washer 1/4 flat plain finish 4
6 999-1865 Screw 6-32 x 5/16 pan head phillips thread cutting ss 4
7 372-1512 Washer 2
8 999-0360 Screw 1/4-20 x 3/8 hex head thread rolling unslotted 24
9 999-1152 Screw 10-24 x 3/8 pan head phillips thread rolling zinc 4
10 272-9677 Screw 1/4-20 x 1/2 hex head 2
11 172-4032 Grommet 1
12 472-5722 CONTACTOR 36V TYPE 4 1
13 472-5775 STUD TYPE JUNCTION BOX 2
14 272-1322 Motor contactor 1
15 172-1779 36V relay SPST 1
16 372-1513 Contactor panel 1
17 372-1515 Current sensor 1
18 372-1516 Delphi clip 3
19 372-1517 Ground bar 1
20 372-1323 Bus bar contactor 2
21 999-0714 Nut 1/2-20 hex jam stainless steel 2
22 172-2805 36V contactor 1 (center brush)
23 172-2805 36V contactor 1 (right brush)
24 172-2805 36V contactor 1 (vacuum motors)
25 172-2805 36V contactor 1 (dust control)
26 172-2805 36V contactor 1 (main broom)
27 272-1322 Motor contactor 1 (hydraulic pump)
28 172-2805 36V contactor 1 (aux)
29 172-2805 36V contactor 1 (steering)
30 172-2805 36V contactor 1 (side brooms)
31 372-1515 Current sensor 1 (vacuum)
32 372-1515 Current sensor 1 (broom)

Engine System Assembly - 372-0060
RefNbr Part Number Description Req Notes
1 999-0829 Screw 5/16-18 x 1 1/4 hex head plain finish 2 (included in KIT1 and KIT2)
2 999-1032 Screw 1/4-20 x 5/8 hex head stainless steel 2 (included in KIT1 and KIT2)
3 999-1532 Screw 1/4-20 x 1/2 hex head stainless steel 3 (LPG model) (included in KIT2)
4 N/A Not available 1 (screw) (LPG model) (only available in KIT2)
5 999-9004 Washer 5/16 SAE flat stainless steel 8 (qty 9 for diesel) (included in KIT1 and KIT2)
6 999-1862 Washer #10 flat SAE stainless steel 1 (LPG model) (included in KIT2)
7 N/A Not available 2 (screw) (qty 4 for diesel) (only available in KIT1 and KIT2)
8 999-0120 Washer 3/8 SAE flat 26 (included in KIT1 and KIT2)
9 999-0567 Screw 1/4-20 x 5/8 pan head phillips stainless steel 6 (included in KIT1 and KIT2)
10 N/A Not available 3 (screw) (included in KIT1 and KIT2)
11 999-0123 Washer 1/4 SAE flat zinc plated 11 (qty 13 for diesel) (included in KIT1 and KIT2)
12 N/A Not available 17 (screw) (qty 15 for diesel) (included in KIT1 and KIT2)
13 999-1857 Screw 5/16-18 x 1 hex cap stainless steel 10 (included in KIT1 and KIT2)
14 999-1531 Screw 3/8-16 x 1 hex washer head zinc plated 8 (qty 12 for diesel) (included in KIT1 and KIT2)
15 999-0211 Nut 5/16-18 hex nylon insert lock zinc plated 8 (included in KIT1 and KIT2)
16 999-1895 Screw 1/4-20 x 7/8 flat head phillips stainless steel 2 (LPG model) (included in KIT2)
17 999-1482 Nut 3/8-16 nylon lock stainless steel 1 (included in KIT1 and KIT2)
18 N/A Not available 4 (nut) (qty 7 for diesel) (only available in KIT1 and KIT2)
19 N/A Not available 5 (nut) (only available in KIT1 and KIT2)
20 N/A Not available 2 (screw) (only available in KIT1 and KIT2)
21 N/A Not available 1 (screw) (only available in KIT1 and KIT2)
22 N/A Not available 4 (washer) (only available in KIT1 and KIT2)
23 999-0894 Screw 3/8-16 x 2 1/2 carriage head stainless steel 1 (included in KIT1 and KIT2)
24 N/A Not available 1 (screw) (only available in KIT1 and KIT2)
25 999-1532 Screw 1/4-20 x 1/2 hex head stainless steel 3 (qty 4 for diesel) (included in KIT1 and KIT2)
26 999-0628 Nut 3/8-16 hex jam stainless steel 1 (LPG model) (included in KIT1 and KIT2)
27 N/A Not available 2 (washer) (only available in KIT1 and KIT2)
28 272-3872 Skid 1
29 272-7994 20 inch hose 1 (qty 2 for diesel)
30 172-9530 Cable clamp 1 (LPG model)
31 172-8493 #24 hose clamp SAE 1 (LPG model)
32 272-3274 Muffler clamp 1
33 272-1317 Plastic clamp 1
34 172-1139 Bushing 6
35 172-1014 P clamp 1
36 472-9240 MOUNT ISOLATOR 4
37 272-9976 #32 hose clamp SAE 2 (qty 3 for diesel)
38 N/A Not available 2 (muffler) (LPG model) (only available in KIT3)
39 272-3288 Service indicator 1
40 272-3270 Air cleaner 1
41 272-3273 Band assembly 1
44 372-2140 Regulator to engine hose 1 (LPG model)
45 372-1534 Tank guard plate 1
46 N/A Not available 1 (engine assembly) (LPG model)
47 372-1600 Tank support weldment 1 (LPG model)
48 N/A Not available 1 (fuel tank assembly) (LPG model)
49 372-2737 Tank support bracket (OBSOLETE) 1 (LPG model)
50 372-2730 Cable guard weldment (OBSOLETE) 1 (LPG model)
51 372-2731 Guard mount weldment (OBSOLETE) 1
52 372-2732 Tailpipe blanket (OBSOLETE) 1 (LPG model)
53 372-1601 Tank mount weldment 1 (LPG model)
54 372-2733 Muffler bracket (OBSOLETE) 1 (LPG model)
55 372-1521 Air cleaner mount weldment 1
56 N/A Not available 1 (tailpipe) (LPG model) (only available in KIT3)
57 372-2734 Muffler blanket (OBSOLETE) 1 (LPG model)
58 372-1537 Belt removal tool 1
59 372-1528 Plate guard 1
60 372-2742 Battery hold down (OBSOLETE) 1 (LPG model)
61 372-1146 Exhaust silencer 1 (LPG model)
62 372-1547 Carbureted exhaust system kit 1 (LPG model)
63 372-1603 Heat shield 1 (LPG model)
64 372-1523 Heat shield muffler 1 (LPG model)
65 372-1524 Foam insulation 1 (LPG model)
66 372-2736 Radiator seal mount 1
67 372-1525 Trim seal 1
68 N/A Not available 1 (tailpipe blanket) (LPG model) (only available in KIT1)
69 170-5169 Hose clamp SAE #4 2 (qty 9 for diesel)
70 272-7769 3/4 inch double wire clamp 4 (qty 5 for diesel)
71 272-7997 Overflow bottle assembly 1
72 999-0830 Screw 1/4-20 x 1 hex head plain finish 4 (diesel model) (included in KIT1)
73 999-0294 Nut 1/4-20 hex nylon lock type NE stainless steel 4 (diesel model) (included in KIT1)
74 999-0990 Screw 1/4-20 x 5/8 flat head phillips stainless steel 2 (diesel model) (included in KIT1)
75 999-0696 Screw 5/16-18 x 1 pan head phillips zinc plated 1 (diesel model) (included in KIT1)
76 172-7339 Pin 1 (diesel model)
77 172-3357 9 inch wire rope 1 (diesel model)
78 172-4008 Bushing 1 (diesel model)
79 272-3286 Hose 1 (diesel model)
80 172-2122 P clamp 1 (diesel model)
81 372-2178 Muffler clamp 1 (diesel model)
82 372-1532 Tank pivot weldment 1 (diesel model)
83 372-1529 Fuel tank support 1 (diesel model)
84 372-1536 Tank pivot bracket 1 (diesel model)
85 372-2737 Tank support bracket (OBSOLETE) 1 (diesel model)
86 372-2738 Tailpipe 1 (diesel model)
87 372-2739 Tailpipe bracket 1 (diesel model)
88 372-2740 Tailpipe blanket (OBSOLETE) 1 (diesel model)
89 372-2741 Muffler blanket (OBSOLETE) 1 (diesel model)
90 372-1522 Mount weldment 1 (diesel model)
91 372-2742 Battery hold down (OBSOLETE) 1 (diesel model)
92 372-2743 Diesel tank assembly 1 (diesel model)
93 372-2744 Fuel hose 1 (diesel model)
N/S N/A Not available 1 (nut) (diesel model) (only available in KIT1)
N/S 272-3351 P clamp 1 (diesel model)
N/S 572-0322 TUBE RUBBER.312X60 E00556 1 (diesel model)
N/S N/A Not available 1 (engine assembly)
N/S 372-2746 Cable bracket weldment 1 (diesel model)
N/S 372-2747 Fuel hose 1 (diesel model)
N/S 272-3775 Double clamp 1 (diesel model)
KIT1 372-2748 Diesel engine hardware kit 1 (includes 1-2, 5, 7, 8-15, 17-25, 27)
KIT2 372-1546 LPG engine system hardware kit 1 (includes 1-27)
KIT3 372-2749 Exhaust system kit 1 (includes 38, 56, 68)

Engine Assembly - 372-0061
RefNbr Part Number Description Req Notes
1 372-2750 Brass plug 1 (diesel model)
2 181-1100 Female hose barb 1
3 999-0114 Washer 1/2 SAE flat 3
4 999-0024 Washer 5/16 flat stainless steel 4 (qty 2 for LPG)
5 999-0558 Bolt 1/2-13 x 1 1/2 hex head stainless steel 2
6 999-0120 Washer 3/8 SAE flat 16 (qty 12 for LPG)
7 999-0123 Washer 1/4 SAE flat zinc plated 15 (qty 11 for LPG)
8 272-1465 Screw 1/4-20 X 5/8 hex head lock 12 (qty 8 for LPG)
9 172-4370 Screw M10-1.25 x 50 mm hex head 6 (diesel model)
10 999-1133 Bolt M8-1.25 x 20mm hex head full thread plain 2 (qty 1 for LPG)
11 999-1424 Nut M8-1.25 hex stainless steel 2 (qty 1 for LPG)
12 472-3516 SCR HEX THD TO HD 1/2-13X2.00 3
13 272-9677 Screw 1/4-20 x 1/2 hex head 4 (diesel model)
14 999-0633 Bolt 1/4-20 x 5/8 hex head stainless steel 3
15 272-7412 Hose clamp 2 (diesel model)
16 372-2751 Hose (OBSOLETE) 1
17 272-7768 Hose clamp 2
18 272-7830 Fuel filter kit 1 (diesel model)
19 272-3351 P clamp 2 (diesel model)
20 172-1337 90 degree barb 1/4 1
21 172-9852 Isolator mount 2
22 172-2122 P clamp 1 (diesel model)
23 372-1550 Engine isolator 2 (qty of 1 for LPG)
24 372-1551 Washer 2
25 272-7818 Electronic fuel pump 1 (diesel model)
26 372-2752 Radiator (OBSOLETE) 1
27a 372-1552 Alternator 1
27b 372-2753 Sheave 1 (for 27a)
27c 372-1553 Sheave 1 (LPG model)
28 372-1567 Belt 1
29 N/A Not available 1 (sheave) (diesel)
30 N/A Not available 1 (engine mount weldment) (diesel model)
31 372-2754 Radiator bracket 1 (diesel model)
32 372-2755 Radiator bracket 1 (diesel model)
33 N/A Not available 1 (spacer plate) (diesel model)
34 N/A Not available 1 (engine assembly) (diesel model)
35a N/A Not available 1 (exhaust assembly) (diesel model)
35b 272-7821 Exhaust gasket 1 (diesel model)
35c 372-1061 Muffler clamp 1 (diesel model)
35d 372-2756 Exhaust pipe weldment 1 (diesel model)
35e 372-2757 Muffler support weldment 1 (diesel model)
35f 372-2758 Hose clamp (OBSOLETE) 1 (diesel model)
35g 372-2161 Muffler 1 (diesel model)
36a N/A Not available 1 (tensioner assembly)
36b 372-1555 Automatic tensioner 1
36c 372-2759 Snap ring (OBSOLETE) 1
36d 372-1556 Bearing 1
36e 372-1557 Idler pulley kit 1
37 372-2760 Air cleaner hose 1 (diesel model)
38 372-1559 Air cleaner hose 1
39 372-2761 Radiator hose 1 (diesel model)
40 372-2762 Radiator hose 1 (diesel model)
41 372-2763 Controller governor 1 (diesel model)
42a 372-2764 Fan guard assembly 1 (diesel model)
42b 372-1562 LPG fan guard assembly 1 (LPG model)
43 372-2765 Guard plate 2 (diesel model)
45 372-1564 Pipe plug 1
46 372-1024 Screw M10-1.25 x 20mm 16 (diesel model)
47 999-9116 Screw M6-1 x 12mm hex head stainless steel 2 (LPG model)
48 999-1383 Screw M6-1 x 16mm hex head stainless steel 2 (LPG model)
49 999-1308 Nut M6-1 hex stainless steel 2 (LPG model)
50 997-2005 Hose clamp 2 (LPG model)
51 272-1587 Clamp hose support (OBSOLETE) 3 (LPG model)
52 N/A Not available 1 (upper radiator mount bracket) (LPG model)
53 N/A Not available 1 (sheave) (LPG model)
54 372-1554 Radiator bracket 1 (LPG model)
55 N/A Not available 1 (engine assembly) (LPG model)
57 372-1558 Air cleaner hose 1 (LPG model)
58 372-1560 Radiator hose 1 (LPG model)
59 372-1561 Radiator hose 1 (LPG model)
60 372-1563 Relay box isolator 2 (LPG model)
61 372-1064 Screw M8-1.25 x 40mm 5 (LPG model)
N/S 372-2767 Kubota harness 1 (diesel model)
N/S 372-2166 Ignition DF-WG972 harness 1 (LPG model)

Engine Sub-Assembly - 372-0062
RefNbr Part Number Description Req Notes
1 181-0983 Screw 5/16-18 x 7/8 hex head 2
2 999-0211 Nut 5/16-18 hex nylon insert lock zinc plated 4 (qty 2 for diesel)
3 999-0294 Nut 1/4-20 hex nylon lock type NE stainless steel 2 (LPG model)
4 999-0893 Screw 5/16-18 x 2 hex head stainless steel 2 (LPG model)
5 999-1905 Screw M6-1 x 60mm hex head zinc plated 4 (LPG model)
6 272-9677 Screw 1/4-20 x 1/2 hex head 4 (qty 3 for diesel)
7 272-7817 Speed sensor 1
8 172-8494 #6 hose clamp SAE 2 (LPG model)
9 272-3351 P clamp 1 (LPG model)
10 172-2122 P clamp 3
11 372-2135 Regulator 1 (LPG model)
12 372-2137 Spark controller 1 (LPG model)
13 372-2787 LP lock off with filter 1 (LPG model)
14 372-2769 Mag pickup bracket 1
15a N/A Not available 1 (exhaust assembly) (LPG model) (includes 15b-15g)
15b 999-9138 Screw M8-1.25 x 25mm socket head stainless steel 1 (included in KIT1) (LPG model)
15c 172-8490 #96 hose clamp SAE 1 (LPG model)
15d N/A Not available 2 (only available in KIT1) (LPG model)
15e 372-1143 Muffler 1 (LPG model)
15f 372-2770 Exhaust spacer 1 (LPG model)
15g 372-2771 Support bracket 1 (LPG model)
16 N/A Not available 1 (coil mount weldment)
17 372-2248 Fan 1
18 N/A Not available 1 (exhaust manifold)
19 372-2785 Controller governor 1 (LPG model)
20 N/A Not available 1 (governer mount bracket) (LPG model)
21 N/A Not available (dipstick assembly) (LPG model)
22a 372-2773 Remote oil drain assembly 1 (LPG model)
22b 372-2793 Drain hose assembly 1 (diesel model)
23 372-2775 Vaporizer hose 2 (LPG model)
24 372-2141 Fuel hose 1 (LPG model)
25 372-2776 Vaporizer hose 1 (LPG model)
26a 372-2784 Engine 1 (LPG model)
26b 372-2791 Engine 1 (diesel model)
27a 372-2779 Fan pulley 1 (LPG model)
27b 272-7755 89mm fan pulley 1 (diesel model)
28a 372-2780 Fan spacer 1 (LPG model)
28b 372-2781 Fan spacer 1 (diesel model)
29 372-2782 Pulley spacer 1 (LPG model)
30 372-2152 Fuel hose 1 (LPG model)
31 170-5169 Hose clamp SAE #4 4 (LPG model)
N/S 372-2783 Low fan kit 1 (diesel model)
N/S 372-2784 Engine 1 (LPG model)
N/S 272-7796 Thermostat kit 1 (LPG model)
N/S 372-2785 Controller governor 1 (LPG model)
N/S 372-1487 Engine interface harness 1
N/S 372-2786 Kubota harness 1 (LPG model)
N/S 372-2166 Ignition DF-WG972 harness 1 (LPG model)
N/S 372-2165 Plug wire/coil kit 1 (LPG model)
N/S 472-7318 SPARK PLUG WIRE KIT-CLY 1 1 (LPG model)
N/S 472-7319 SPARK PLUG WIRE KIT- CYL 2 1 (LPG model)
N/S 472-7320 SPARK PLUG WIRE KIT- CYL 3 1 (LPG model)
N/S 372-2157 Spark plug 3 (LPG model)
N/S 372-2787 LP lock off with filter 1 (LPG model)
N/S 372-2158 Starter motor 1 (LPG model)
N/S 272-7814 Temperature switch 1
N/S 372-2159 Water pump assembmly 1 (LPG model)
N/S 372-1231 Oil filter cartridge 1 (LPG model)
N/S 372-2789 Dipstick 1 (LPG model)
N/S 372-2160 Exhaust gasket donut 1 (LPG model)
N/S 472-9176 SWITCH ENGINE OIL PRESSURE 1 (LPG model)
N/S 372-1143 Muffler 1 (LPG model)
N/S 372-2790 Fan belt 1 (LPG model)
N/S 372-1560 Radiator hose 1 (LPG model)
N/S 372-1558 Air cleaner hose 1 (LPG model)
N/S 372-1559 Air cleaner hose 1
N/S 372-2791 Engine 1 (diesel model)
N/S 372-2792 Alternator 1 (diesel model)
N/S 272-7808 Fuel filter cartridge 1 (diesel model)
N/S 272-7809 Oil filter cartridge 1 (diesel model)
N/S 472-9174 ALTERNATOR BELT 1 (diesel model)
N/S 272-7747 Fan belt 1 (diesel model)
N/S 272-7796 Thermostat kit 1 (diesel model)
N/S 272-7812 Starter motor 1 (diesel model)
N/S 272-7813 Oil pressure switch 1 (diesel model)
N/S 272-7815 Throttle shut down actuator 1 (diesel model)
N/S 372-2763 Controller governor 1 (diesel model)
N/S 272-7817 Speed sensor 1 (diesel model)
N/S 372-2761 Radiator hose 1 (diesel model)
N/S 372-2762 Radiator hose 1 (diesel model)
N/S 372-2793 Drain hose assembly 1 (diesel model)
N/S 272-7818 Electronic fuel pump 1 (diesel model)
N/S 272-3327 Strainer 1 (diesel model)
N/S 372-2760 Air cleaner hose 1 (diesel model)
KIT1 372-1141 Exhaust gasket kit (OBSOLETE) 1 (includes 15b and 15d)

Diesel Fuel Tank Assembly - 372-0063
RefNbr Part Number Description Req Notes
1 999-0123 Washer 1/4 SAE flat zinc plated 4
2 272-1562 Screw 1/4-20 x 3/5 pan head thread forming 1
3 272-9677 Screw 1/4-20 x 1/2 hex head 4
4 172-2303 Rubber boot 1
5 372-1571 Fuel tank assembly 1
6 372-1569 90 degree elbow 2
7 372-2794 Tank support bracket (OBSOLETE) 1
N/S 272-7868 Fuel cap 1
N/S 372-2795 Fuel level sender 1
N/S 372-2796 Fuel withdraw tube (OBSOLETE) 1
N/S 372-2797 Fuel return tube (OBSOLETE) 1

Hopper Assembly 1 - 372-0064
RefNbr Part Number Description Req Notes
1 172-4018 Strain relief 1
5 999-0333 Screw 10-24 x 1/2 pan head phillips stainless steel 2 (included in KIT4)
7 999-1207 Screw 5/16-18 x 2 1/2 hex head stainless steel 1 (included in KIT4)
8 999-0294 Nut 1/4-20 hex nylon lock type NE stainless steel 8 (included in KIT3)
12 999-0211 Nut 5/16-18 hex nylon insert lock zinc plated 13 (included in KIT2)
13 999-0123 Washer 1/4 SAE flat zinc plated 4 (included in KIT2)
14 999-0916 Screw 8-32 x 1/2 pan head phillips stainless steel 8 (included in KIT1 and KIT4)
19 N/A Not available 4 (screw) (only available in KIT2)
20 N/A Not available 1 (screw) (only available in KIT4)
21 999-1232 Screw 5/16-18 x 3/4 hex head stainless steel 3 (included in KIT4)
28 N/A Not available 6 (screw) (only available in KIT3 and KIT4)
29 N/A Not available 4 (washer) (only available in KIT4)
30 N/A Not available 13 (screw) (only available in KIT2)
34 N/A Not available 15 (washer) (only available in KIT2 and KIT4)
36 372-2798 Tie anchor 2
37 N/A Not available 2 (latch) (only available in KIT1)
38a 372-2319 Head light assembly 2
38b 272-7703 Headlight replacement bulb 1 (for 38a)
42 372-2799 Plug 1
44 N/A Not available 1 (hopper flap) (only available in KIT3)
45 N/A Not available 1 (hopper flap clamp) (only available in KIT3)
49 372-2800 Hopper seal 1
50 372-2801 Lower hopper 1
51 372-2802 Upper hopper 1
52a N/A Not available 1 (hopper cover assembly) (only available in KIT1)
52b N/A Not available 1 (strain relief) (only available in KIT1)
52c 999-0123 Washer 1/4 SAE flat zinc plated 5 (included in KIT1)
52d N/A Not available 5 (screw) (only available in KIT1)
52e N/A Not available 2 (bearing) (only available in KIT1)
52f N/A Not available 1 (hopper cover) (only available in KIT1)
52g N/A Not available 1 (hopper cover seal) (only available in KIT1)
52h N/A Not available 1 (left hopper cover hinge) (only available in KIT1)
52i N/A Not available 1 (right hopper cover hinge) (only available in KIT1)
52j N/A Not available 1 (hopper cover seal) (only available in KIT1)
57 372-2803 Vented cap with tether 1
60 N/A Not available 1 (hopper skid plate) (only available in KIT2)
63 N/A Not available 1 (hopper skid weldment) (only available in KIT2)
KIT1 372-2804 Hopper cover kit 1 (includes 14, 37, 52a-52j)
KIT2 372-2805 Skid plate kit 1 (includes 12-13, 19, 30, 34, 60-63)
KIT3 372-2805 Skid plate kit 1 (includes 8, 28, 44-45)
KIT4 372-2807 Hardware kit 1 (includes 5, 7, 14, 20-21, 28-29, 34)

Hopper Assembly 2 - 372-0065
RefNbr Part Number Description Req Notes
2 172-9507 Leveler 2
3 N/A Not available 3 (screw) (only available in KIT4)
4 N/A Not available 2 (screw) (only available in KIT4)
6 999-0412 Washer #8 SAE flat 5 (included in KIT4)
8 999-0294 Nut 1/4-20 hex nylon lock type NE stainless steel 8 (included in KIT3)
9 999-0442 Nut 10-24 nylon insert lock stainless steel 3 (included in KIT4)
10 N/A Not available 1 (nut) (only available in KIT4)
11 N/A Not available 2 (nut) (only available in KIT4)
15 999-0297 Bolt 1/4-20 x 1 hex head stainless steel 5
16 999-9128 Washer 3/8 SAE flat stainless steel 4 (included in KIT4)
17 999-1489 Screw 3/8-16 x 1 1/2 hex head stainless steel 4 (included in KIT4)
18 999-6684 Washer 1/4 flat stainless steel 2 (included in KIT4)
21 999-1232 Screw 5/16-18 x 3/4 hex head stainless steel 3 (included in KIT4)
22 N/A Not available 1 (clevis pin) (only available in KIT4)
23 999-1482 Nut 3/8-16 nylon lock stainless steel 4 (included in KIT4)
24 N/A Not available 2 (cotter hair pin) (only available in KIT4)
25 N/A Not available 2 (ring) (only available in KIT4)
26 N/A Not available 1 (clevis pin) (only available in KIT4)
27 N/A Not available 3 (washer) (only available in KIT4)
28 N/A Not available 6 (screw) (only available in KIT3 and KIT4)
31 N/A Not available 2 (ring) (only available in KIT4)
32 999-0050 Nut 1/2-13 hex jam plain finish 2 (included in KIT4)
35 272-8850 Proximity sensor 3
39 272-8754 Conduit clip 1
40 372-2337 Cylinder pin 1
41 372-2818 Flange bearing 2
43a 372-2809 Dump door assembly 1 (includes 43b-43l)
43b 999-0294 Nut 1/4-20 hex nylon lock type NE stainless steel 13
43c 999-0297 Bolt 1/4-20 x 1 hex head stainless steel 7
43d 272-3627 Screw 1/4-20 x 3/4 carriage head stainless steel 6
43e 172-0553 Washer 17/64 x 1/16 flat 2
43f 572-0622 CLAMP HOPPER DOOR SIDE SEAL 2
43g 572-0623 SEAL HOPPER DOOR SIDE 2
43h 372-2810 Hopper door weldment 1
43i 372-2811 Dump door pivot weldment 1
43j 372-2812 Hopper door bottom seal 1
43k 372-2813 Hopper door bottom clamp 2
43l 372-2814 Hopper door bottom seal 2
46 N/A Not available 1 (hopper door bottom clamp) (only available in KIT5)
47 372-2815 Hopper lift weldment 1
48 372-2816 Bearing 1
53a 372-2817 Dump door actuator assembly 1 (includes 53b-53h)
53b 999-0114 Washer 1/2 SAE flat 2
53c 172-4393 Pin .50 x 3.00 clevis 1
53d 997-2518 Hitch pin 1
53e 372-2818 Flange bearing 1
53f 372-2819 Dump door actuator 1
53g 372-2820 Dump door actuator yoke (OBSOLETE) 1
53h 372-2821 Compression spring (OBSOLETE) 1
54 472-7936 BRACKET-SENSOR MOUNTING 1
55 372-2822 Prop rod assembly 1
56 372-2823 Hopper hinge bar 1
58 N/A Not available 1 (hopper door seal clamp) (only available in KIT5)
59 N/A Not available 1 (hopper door seal) (only available in KIT5)
64 372-3257 Gas spring 1
KIT3 372-2806 Hopper flap kit 1 (includes 8 and 28)
KIT4 372-2807 Hardware kit 1 (includes 3-4, 6, 9-11, 16-18, 21-28, 31-32)
KIT5 372-2825 Hopper door seal kit 1 (includes 58-59)

Hydraulic System Assembly - 372-0066
RefNbr Part Number Description Req Notes
1 272-3209 Left hinge pin weldment 1
2 272-9727 Screw 1/4-20 x 1/2 hex head lock 1
3 272-1652 Bolt 3/8-16 x 5/6 lock 2
4 999-0793 Screw 10-24 x 3/8 hex washer slot thread cutting zinc 1
5 272-8806 P clamp 1
6a 372-2832 Hydraulic power pack assembly 1 (includes 6b-6e)
6b 372-2833 36V motor 1
6c 372-2834 Hydraulic pump/reservoir assembly 1
6d 372-2835 Orifice fitting 1
6e 272-2983 90 degree elbow 2
6f 372-2836 Hydraulic reservoir kit 1 (for 6c)
6g 372-2837 Hydraulic reservoir cap 1 (for 6c)
6h 472-7032 O-RING -132 NBR 70 HC350B 1 (for 6c)
7a N/A Not available 1 (hopper lift cylinder assembly) (includes 7b-7e)
7b 372-2818 Flange bearing 2
7c 372-2838 Hydraulic cylinder 1
7d 272-2983 90 degree elbow 1
7e 272-3151 90 degree elbow 1
7f 372-2839 Seal kit 1 (for 7c)
8 372-2840 Hose assembly 2

LPG Tank Assembly - 372-0067
RefNbr Part Number Description Req Notes
1 N/A Not available 1 (bushing) (only available in KIT2)
2 999-0829 Screw 5/16-18 x 1 1/4 hex head plain finish 1 (included in KIT2)
3 999-1032 Screw 1/4-20 x 5/8 hex head stainless steel 2 (included in KIT2)
4 999-6684 Washer 1/4 flat stainless steel 3 (included in KIT2)
5 999-9004 Washer 5/16 SAE flat stainless steel 2 (included in KIT2)
6 999-0123 Washer 1/4 SAE flat zinc plated 1 (included in KIT2)
7 999-0294 Nut 1/4-20 hex nylon lock type NE stainless steel 3 (included in KIT2)
8 999-0457 Screw 1/4-20 x 3/4 flat head phillips stainless steel 2 (included in KIT2)
9 N/A Not available 1 (nut) (only available in KIT2)
10 N/A Not available 1 (screw) (only available in KIT2)
11 999-0050 Nut 1/2-13 hex jam plain finish 1 (included in KIT2)
12 N/A Not available 1 (screw) (only available in KIT2)
13 N/A Not available 1 (screw) (only available in KIT1 and KIT2)
14 172-9530 Cable clamp 1
15 N/A Not available 1 (right latch) (only available in KIT1)
16 272-3359 LP tank 1
17 272-7880 Toggle 1
18 272-1613 P clamp 3
19 N/A Not available 1 (pin) (only available in KIT1)
20 372-2826 Fuel tank mount weldment 1
21a 372-2827 LP filter assembly 1 (includes 21b-21m)
21b 272-3355 45 degree elbow, male 2
21c 172-4330 Nut 7/8-14 hex jam 1
21d 272-2073 Elbow 1
21e 272-7886 45 degree SAE adapter 1
21f 272-7275 Female coupler 1
21g 272-3353 Switch N C Pressure 1
21h 272-3357 Bulkhead fitting 1
21i 272-7887 Dust boot 1
21j 272-3356 1/4 NPT vent 1
21k 372-2828 LPG hose assembly 1
21l 372-2829 LPG hose assembly 1
21m 272-3337 Tee 1
KIT1 372-2830 Tank latch kit 1 (includes 13, 15, 19)
KIT2 372-2831 Hardware kit 1 (includes 1-13)

Main Broom Assembly - 372-0068
RefNbr Part Number Description Req Notes
1 472-2965 BROOM-MAIN PROLENE/WIRE STD 1
2 999-0294 Nut 1/4-20 hex nylon lock type NE stainless steel 4 (included in KIT6
3 N/A Not available 1 (cotter pin) (only available in KIT6)
4 N/A Not available 1 (screw) (only available in KIT5)
5 N/A Not available 8 (screw) (only available in KIT1)
6 999-1208 Nut 1/2-13 nylon insert lock stainless steel 2 (included in KIT6)
7 N/A Not available 5 (nut) (only available in KIT7)
8 999-0123 Washer 1/4 SAE flat zinc plated 5 (included in KIT6 and KIT7)
9 999-0830 Screw 1/4-20 x 1 hex head plain finish 1 (included in KIT7)
10 N/A Not available 2 (screw) (only available in KIT6)
11 N/A Not available 2 (screw) (only available in KIT6)
12 999-0114 Washer 1/2 SAE flat 2 (included in KIT6)
13 999-0456 Screw 1/4-20 x 3/4 pan head phillips stainless steel 6 (included in KIT4)
14 N/A Not available 1 (clevis pin) (only available in KIT6)
15 999-1482 Nut 3/8-16 nylon lock stainless steel 3 (included in KIT5 and KIT7)
16 N/A Not available 1 (key) (only available in KIT6 and KIT7)
17 N/A Not available 3 (clevis pin) (only available in KIT5)
18 N/A Not available 4 (screw) (only available in KIT6)
19 N/A Not available 1 (clevis pin) (only available in KIT5)
20 N/A Not available 3 (bow tie cotter pin) (only available in KIT5)
21 N/A Not available 1 (bow tie cotter pin) (only available in KIT5)
22a N/A Not available 4 (screw) (only available in KIT2 and KIT6)
22b N/A Not available 1 (screw) (only available in KIT7)
23 N/A Not available 1 (washer) (only available in KIT6 and KIT7)
24 N/A Not available 2 (flange bearing) (only available in KIT5)
25 170-6734 Strap static 1
26 N/A Not available 2 (bearing) (only available in KIT6)
27 N/A Not available 1 (broom lift actuator) (only available in KIT5)
28 N/A Not available 1 (spring arm) (only available in KIT5)
29 N/A Not available 1 (extension spring) (only available in KIT5)
30 N/A Not available 1 (right skirt foam) (only available in KIT4)
31 N/A Not available 1 (left skirt foam) (only available in KIT4)
32 N/A Not available 1 (right skirt) (only available in KIT4)
33 N/A Not available 1 (left skirt) (only available in KIT4)
34 N/A Not available 2 (skirt strap) (only available in KIT4)
35 372-2841 Left hand skirt strap 1
36 372-2842 Panel weldment 1
37 N/A Not available 1 (broom support weldment) (only available in KIT6)
38a 372-2843 Broom arm assembly 1 (includes 38b-38g)
38b 172-4412 Retaining ring 1
38c 999-0493 Bolt 3/8-16 x 3/4 hex head stainless steel 1
38d 172-1939 Washer 13/32 x 1 1/4 x 5/32 1
38e 172-9411 Ball bearing 2
38f 372-2843 Broom arm assembly 1
38g 372-2845 Broom idler hub 1
39a 372-2846 Broom door assembly 1 (includes 39b-39k)
39b 999-0294 Nut 1/4-20 hex nylon lock type NE stainless steel 2
39c 999-0335 Washer 1/4 x 5/8 SAE flat stainless steel 3
39d 172-3280 Screw 5/16 - 18 x 5/8 hex lock stainless steel 3
39e 999-0334 Bolt 1/4-20 x 3/4 inch hex head stainless steel 2
39f 472-3509 SCR SOC SHD .31X.25X1/4-20 1
39g 472-3555 SCR-HEX SS 1/4-20 X .88 1
39h 272-9692 Right hand latch 1
39i 372-2847 Broom door weldment 1
39j 372-2848 Broom door seal 1
39k 372-2849 Stop arm 1
40 N/A Not available 1 (broom drive assembly hub) (only available in KIT6)
41a N/A Not available 1 (broom motor assembly) (only included in KIT2)
41b 372-2854 Brush motor kit 1 (for 41a) (included in KIT3)
42 N/A Not available 1 (broom flap) (only available in KIT1)
43 N/A Not available 1 (rear broom skirt) (only available in KIT1)
44 N/A Not available 2 (rear broom strap) (only available in KIT1)
45 N/A Not available 1 (washer) (only available in KIT7)
46 N/A Not available 1 (washer) (only available in KIT7)
47 N/A Not available 1 (bolt) (only available in KIT7)
48 999-0635 Nut 3/8-16 hex stainless steel 1 (included in KIT7)
N/S 472-2965 BROOM-MAIN PROLENE/WIRE STD 1
N/S 472-2963 BROOM-MAIN NYLON 1 (optional)
N/S 472-2964 BROOM-MAIN PROLENE 1 (optional)
N/S 372-2851 Main broom natural/union mix (OBSOLETE) 1 (optional)
KIT1 372-2852 Rear broom strap kit 1 (includes 5, 42-44)
KIT2 372-2853 Broom motor kit 1 (includes 22 and 41)
KIT3 372-2854 Brush motor kit 1 (includes 41b)
KIT4 372-2855 Broom skirt kit 1 (includes 13, 30-34)
KIT5 372-2856 Main broom actuator kit 1 (includes 4, 15, 17, 19-21, 24, 27-29)
KIT6 372-2857 Main broom support kit 1 (includes 2-3, 6, 8, 10-12, 16, 18, 22, 23, 26, 37, 40)
KIT7 372-2858 Main broom hardware kit 1 (includes 7-9, 15-16, 22-23, 45-48)

Recovery System Assembly - 372-0069
RefNbr Part Number Description Req Notes
1 999-0822 Screw 1/4-20 x 7/8 hex head plain finish 1 (included in KIT5)
2 999-6684 Washer 1/4 flat stainless steel 6 (included in KIT5)
3 999-0333 Screw 10-24 x 1/2 pan head phillips stainless steel 3 (included in KIT5)
4 999-0567 Screw 1/4-20 x 5/8 pan head phillips stainless steel 6 (included in KIT5)
5 999-1030 Screw 1/4-20 x 2 pan head phillips stainless steel 1 (included in KIT5)
6 999-0024 Washer 5/16 flat stainless steel 12 (included in KIT5)
7 999-1232 Screw 5/16-18 x 3/4 hex head stainless steel 12 (included in KIT5)
8 999-0152 Nut 1/4-20 nylon insert lock zinc plated 1 (included in KIT5)
9 999-0332 Screw 10-24 x 5/8 pan head phillips stainless steel 6 (included in KIT4)
10 999-0599 Screw 1/4-20 x 1 3/4 pan head phillips stainless steel 4 (included in KIT5)
11 999-0452 Screw 8-32 x 3/8 pan head phillips zinc plated 8 (included in KIT5)
12 N/A Not available 2 (screw) (only available in KIT5)
13 N/A Not available 6 (washer) (only available in KIT5)
14 N/A Not available 3 (clamp) (only available in KIT4)
15 272-0430 Vacuum duct gasket 2
16 172-0162 Bushing 1
17 272-9973 Quick link cable assembly 1
18 272-9976 #32 hose clamp SAE 2
19 N/A Not available 1 (hose clamp) (only available in KIT3)
20 172-2122 P clamp 1
21 372-2036 Hopper cover latch 1
22 372-2283 Shrink tube 3/4 x 2 1/2 1
23 372-2859 Tank pivot weldment (OBSOLETE) 2
24 372-2860 Recovery tank 1
25 372-2861 Exhaust cover 1
26 372-2862 Latch pin weldment 1
27 372-2863 Recovery tank cover 1 (included in KIT1)
28 372-2864 Tether hook 1
29 372-2865 Cover plate 1
30a N/A Not available 1 (vacuum fan cover assembly) (includes 30b-30o)
30b 999-0567 Screw 1/4-20 x 5/8 pan head phillips stainless steel 2
30c 272-9978 Screw 10-14 x 1/2 pan head phillips plastite 2
30d 272-1601 Screw 1/4-14 X 5/8 pan head phillips type B 4
30e 172-3357 9 inch wire rope 1
30f N/A Not available 4 (float cage) (only available in KIT2)
30g N/A Not available 2 (float ball) (only available in KIT2)
30h 272-9980 Filter screen 1
30i 272-9981 Filter 1
30j 172-0185 Bushing 2
30k 372-2866 Vacuum fan cover 1
30l 372-2867 Vacuum fan top gasket 1
30m 372-2868 Vacuum cover plate 1
30n 372-2869 Latch (plastic) 2
30o 372-2870 Vacuum filter lid assembly 1
31 372-2871 Squeegee hose 1
32 372-2872 Hinge tab 2
33 372-2873 Inlet plate 1
34 372-2874 36V vacuum motor 2
35 372-2875 Isolator mount 4
36 372-2876 Recovery tank cover gasket 1 (included in KIT1)
37 372-2877 Debris basket 1
38 372-2878 Cover gasket 2
39 372-2879 Seal trim 1
40 372-2880 Foam tube assembly 2
41 372-2881 Tank gasket 1
42 372-2882 Inlet plate gasket 1
43 372-2883 Foam isolator 5
44 372-1144 Vacuum fan seal assembly 1
45 272-7220 Drain hose 1 (included in KIT3)
KIT1 372-2884 Recovery lid kit 1 (includes 27 and 36)
KIT2 372-2885 Float ball cage kit 1 (includes 30f-30g)
KIT3 472-7846 DRAIN HOSE KIT 1 (includes 19 and 45)
KIT4 372-2886 Drain hose clip kit 1 (includes 9 and 14)
KIT5 372-2887 Recovery system hardware kit 1 (includes 1-8, 10-13)

Scrub System Assembly - 372-0070
RefNbr Part Number Description Req Notes
1 999-0294 Nut 1/4-20 hex nylon lock type NE stainless steel 6 (included in KIT1)
2 999-0442 Nut 10-24 nylon insert lock stainless steel 1 (included in KIT1)
3 N/A Not available 2 (nut) (only available in KIT1)
4 999-0123 Washer 1/4 SAE flat zinc plated 4 (included in KIT1)
5 999-0830 Screw 1/4-20 x 1 hex head plain finish 2 (included in KIT1)
6 999-0332 Screw 10-24 x 5/8 pan head phillips stainless steel 1 (included in KIT1)
7 999-0114 Washer 1/2 SAE flat 7 (included in KIT1)
8 N/A Not available 2 (screw) (only available in KIT1)
9 N/A Not available 2 (clevis pin) (only available in KIT1)
10 N/A Not available 2 (bow tie cotter pin) (only available in KIT1)
11 N/A Not available 2 (screw) (only available in KIT1)
12 999-0822 Screw 1/4-20 x 7/8 hex head plain finish 4 (included in KIT1)
13 997-2005 Hose clamp 2
14 272-8850 Proximity sensor 1
15 172-0024 Bushing 4
16 172-9354 Spiral hose for disc models 1
17 272-1843 Flanged bearing 4
18 997-2102 Cable tie 1
19 N/A Not available 1 (deck assembly)
20a N/A Not available 1 (deck lift arm assembly) (includes 20b-20m)
20b 472-3556 SCR-HEX SS 3/8-16 X 7.0 1
20c 999-9071 Nut 3/8-16 nylon insert jam lock stainless steel 1
20d 999-0355 Washer 3/8 x 7/8 SAE flat stainless steel 2
20e 472-3540 PIN-BOW-TIE COT 1/4-3/8X.072 1
20f 172-1939 Washer 13/32 x 1 1/4 x 5/32 1
20g 172-8815 Flanged bearing 2
20h 372-3287 Deck lift weldment 1
20i 372-3287 Deck lift weldment 1
20j 372-2889 Spacer 1
20k 372-2890 Arm lift spring 1
20l 272-3552 Compression spring 2
20m 372-2891 Clevis pin 1
21 372-2892 Scrub deck actuator 1
22 372-2893 Target sensor bracket 1
23 372-2894 Positive stop bracket 1
24 372-2895 Scrub deck stop 1
KIT1 372-2896 Scrub system hardware kit 1 (includes 1-12)

Scrub System Deck Assembly - 372-0071
RefNbr Part Number Description Req Notes
1 N/A Not available 2 (nut) (only available in KIT1)
2 N/A Not available 1 (nut) (only available in KIT1)
3 999-0423 Nut 5/16-18 nylon insert lock stainless steel 4 (included in KIT1)
4 N/A Not available 2 (screw) (only available in KIT1)
5 999-1857 Screw 5/16-18 x 1 hex cap stainless steel 5 (included in KIT1)
6 999-0114 Washer 1/2 SAE flat 5 (included in KIT1)
7 999-9004 Washer 5/16 SAE flat stainless steel 3 (included in KIT1)
8 999-1667 Screw 5/16-18 x 1 1/4 socket head stainless steel 3 (included in KIT1)
9 N/A Not available 3 (key) (only available in KIT1)
10 999-1857 Screw 5/16-18 x 1 hex cap stainless steel 4 (included in KIT1)
11 N/A Not available 12 (screw) (only available in KIT1)
12 N/A Not available 1 (screw) (only available in KIT1)
13 999-1019 Nut 5/16-18 hex jam stainless steel 1 (included in KIT1)
14 997-2004 Hose clamp 4
15 272-2193 Solenoid valve assembly 1
16 272-2213 Coupler 1/2 x 3/4 barb 3
17 272-5788 Solution manifold 1
18 372-2346 Bearing 1 x 1 1/4 x 1/2 2
19 372-2897 Arm weldment (OBSOLETE) 1
20 372-2898 Deck weldment (OBSOLETE) 1
21 372-2899 Pivot plate 1
22 N/A Not available 1 (side squeegee assembly)
23 N/A Not available 1 (side squeegee assembly)
24 372-2900 Lever arm bracket 1
25 372-2901 Motor spacer 3
26 372-2902 Scrub adjustment bracket (OBSOLETE) 1
27 372-2903 Gas spring 1
28 372-2904 Hose push lock 14 1
29 372-2905 Hose push lock 17.5 1
30 372-2906 Hose push lock 16 1
31a 372-2907 Scrub motor assembly (OBSOLETE) 2
31b 572-4029 Brush motor kit 1 (for 31a)
32a 372-2908 Scrub motor assembly 1
32b 572-4029 Brush motor kit 1 (for 32a)
33a 372-1331 Brush plate assembly 2 (includes 33b-33i)
33b 172-0155 Stop plate 1
33c 272-5779 Spring retainer 1
33d 172-0553 Washer 17/64 x 1/16 flat 1
33e 999-1833 Screw 10-14 x 3/8 pan head phillips stainless steel 3
33f 272-9884 Brush holder spring 1
33g 272-9885 Brush plate 1
33h 272-7257 6 tab gimbal and collar assembly 1
33i 170-0233 Brush driver collar - See pop-up (OBSOLETE) 1
34 372-1332 Brush plate assembly 1 (use same components as 33a)
KIT1 372-2909 Deck assembly hardware kit 1 (includes 1-13)

Right Skirt Assembly - 372-0072
RefNbr Part Number Description Req Notes
1 N/A Not available 2 (bushing) (only available in KIT1)
2 N/A Not available 6 (nut) (only available in KIT4)
3 999-0423 Nut 5/16-18 nylon insert lock stainless steel 9 (included in KIT1 and KIT3)
4 999-0829 Screw 5/16-18 x 1 1/4 hex head plain finish 8 (included in KIT1)
5 999-0336 Screw 6-32 x 3/8 pan head phillips stainless steel 2 (included in KIT2)
6 999-9004 Washer 5/16 SAE flat stainless steel 8 (included in KIT1)
7 N/A Not available 2 (nut) (only available in KIT2)
8 999-0457 Screw 1/4-20 x 3/4 flat head phillips stainless steel 6 (included in KIT4)
9 N/A Not available 1 (screw) (only available in KIT3)
10 N/A Not available 2 (wing knob) (only available in KIT3)
11 172-2150 Knob 1
12 N/A Not available 8 (flange bearing) (only available in KIT1)
13 N/A Not available 6 (bushing) (only available in KIT1)
14 N/A Not available 1 (latch assembly) (only available in KIT2)
15 372-2910 Blade support weldment 1
16 372-2911 Blade kit red gum 1 (all deck blade kits include all blades for both skirt assemblies)
17 N/A Not available 1 (blade strap) (only available in KIT2)
19 372-2912 Weldment strap 1
20 372-2913 Scrub edge guard 1
21 N/A Not available 1 (guard) (only available in KIT4)
22 372-2914 Catch plate 1 (included in KIT1)
23 372-2915 Extension spring 2 (included in KIT1)
24 N/A Not available 1 (side squeegee weldment arm) (only available in KIT1)
25 N/A Not available 1 (side squeegee weldment arm) (only available in KIT1)
N/S 372-2911 Blade kit red gum 1 (all deck blade kits include all blades for both skirt assemblies)
N/S 372-2916 Blade kit gum rubber 1 (all deck blade kits include all blades for both skirt assemblies) (optional)
N/S 372-2917 Blade kit polyurethane 1 (all deck blade kits include all blades for both skirt assemblies) (optional)
KIT1 372-2918 Left hand squeegee arm kit 1 (includes 1, 3-4, 6, 12-13, 22-25)
KIT2 372-2919 Side squeegee strap kit 1 (includes 5, 7, 14, 17)
KIT3 372-2920 Right hand squeegee hardware kit 1 (includes 3, 9-10)
KIT4 372-2921 Guard kit 1 (includes 2, 8, 21)

Left Skirt Assembly - 372-0073
RefNbr Part Number Description Req Notes
1 N/A Not available 2 (bushing) (only available in KIT1)
2 999-0423 Nut 5/16-18 nylon insert lock stainless steel 8 (included in KIT1)
3 999-0829 Screw 5/16-18 x 1 1/4 hex head plain finish 8 (included in KIT1)
4 999-0336 Screw 6-32 x 3/8 pan head phillips stainless steel 4 (included in KIT2 and KIT3)
5 999-9004 Washer 5/16 SAE flat stainless steel 8 (included in KIT1)
6 N/A Not available 4 (nut) (only available in KIT2 and KIT3)
7 472-6259 SPRING EXTENSION 1 (included in KIT1)
8 N/A Not available 8 (flange bearing) (only available in KIT1)
9 N/A Not available 6 (bushing) (only avilable in KIT1)
10 N/A Not available 2 (latch assembly) (only available in KIT2 and KIT3)
11 372-2922 Blade support weldment 1
12 372-2914 Catch plate 1 (included in KIT1)
13 372-2915 Extension spring 1 (included in KIT1)
14 N/A Not available 1 (side squeegee weldment arm) (only available in KIT1)
15 N/A Not available 1 (side squeegee weldment arm) (only available in KIT1)
16 N/A Not available 1 (blade strap) (only available in KIT2)
17 372-2911 Blade kit red gum 1 (all deck blade kits includes all blades for both skirt assemblies)
18 N/A Not available 1 (blade strap) (only available in KIT3)
N/S 372-2911 Blade kit red gum 1 (all deck blade kits includes all blades for both skirt assemblies)
N/S 372-2916 Blade kit gum rubber 1 (all deck blade kits includes all blades for both skirt assemblies) (optional)
N/S 372-2917 Blade kit polyurethane 1 (all deck blade kits includes all blades for both skirt assemblies) (optional)
KIT1 372-2918 Left hand squeegee arm kit 1 (includes 1-3, 5, 7-9, 12-15)
KIT2 372-2923 Left hand front squeegee strap kit 1 (includes 4, 6, 10, 16)
KIT3 372-2924 Left hand rear squeegee strap kit 1 (includes 4, 6. 10, 18)

Side Broom System Assembly - 372-0074
RefNbr Part Number Description Req Notes
1 N/A Not available 1 (nut) (only available in KIT4)
2 N/A Not available 2 (nut) (only available in KIT4)
3 999-0423 Nut 5/16-18 nylon insert lock stainless steel 4 (included in KIT1)
4 999-1857 Screw 5/16-18 x 1 hex cap stainless steel 4 (included in KIT1)
5 999-0114 Washer 1/2 SAE flat 2 (included in KIT4)
6 999-9004 Washer 5/16 SAE flat stainless steel 4 (included in KIT1)
7 N/A Not available 2 (screw) (only available in KIT4)
8 999-1136 Screw 1/4-20 x 7/8 pan head phillips stainless steel 2 (included in KIT4)
9 N/A Not available 1 (cotter hair pin) (only available in KIT4)
10 N/A Not available 4 (screw) (only available in KIT4)
11 N/A Not available 2 (screw) (only available in KIT4)
12 N/A Not available 2 (bearing) (only available in KIT1)
13 272-7198 36V actuator 1
14 372-2925 Side broom lift weldment 1
15a 372-2926 Right hand broom assembly 1 (includes 15b-15w)
15b 999-0882 Screw 3/8-16 x 3/4 hex head hot dipped galvanized 1 (included in KIT2)
15c 999-1208 Nut 1/2-13 nylon insert lock stainless steel 2 (included in KIT2)
15d 999-0830 Screw 1/4-20 x 1 hex head plain finish 1 (included in KIT2)
15e 999-0114 Washer 1/2 SAE flat 2 (included in KIT2)
15f 999-0456 Screw 1/4-20 x 3/4 pan head phillips stainless steel 1 (included in KIT2 and KIT5)
15g 999-0181 Nut 1/4-20 hex jam plain finish 2 (included in KIT2 and KIT5)
15h N/A Not available 1 (pin) (only available in KIT5)
15i N/A Not available 2 (screw) (only available in KIT2)
15j N/A Not available 4 (screw) (only available in KIT5)
15k N/A Not available 1 (washer) (only available in KIT2)
15l 181-0142 Extension spring 1
15m 272-3956 Right hand thumb nut 1
15n N/A Not available 2 (bushing) (only available in KIT2)
15o N/A Not available 1 (bushing) (only available in KIT2)
15p 372-2927 Side broom hub assembly 1
15q 372-2928 Side broom guard 1
15r N/A Not available 1 (right hand motor braket weldment) (only available in KIT2)
15s N/A Not available 1 (right hand squeegee blade arm assembly) (only available in KIT2)
15t 472-8233 SIDE BROOM MOTOR KIT 1
15u N/A Not available 1 (lift bracket) (only available in KIT2)
15v N/A Not available 1 (cable assembly) (only available in KIT2)
15w 372-2929 Side broom 1
16a 372-2930 Left hand broom assembly 1 (includes 16b-16w)
16b N/A Not available 1 (screw) (only available in KIT3)
16c 999-1208 Nut 1/2-13 nylon insert lock stainless steel 2 (included in KIT3)
16d 999-0830 Screw 1/4-20 x 1 hex head plain finish 1 (included in KIT3)
16e 999-0114 Washer 1/2 SAE flat 2 (included in KIT3)
16f 999-0456 Screw 1/4-20 x 3/4 pan head phillips stainless steel 1 (included in KIT3 and KIT5)
16g 999-0181 Nut 1/4-20 hex jam plain finish 2 (included in KIT3 and KIT5)
16h N/A Not available 1 (pin) (only available in KIT5)
16i N/A Not available 2 (screw) (only available in KIT3)
16j 999-1312 Screw M6-1 x 20mm hex head stainless steel 4 (included in KIT5)
16k N/A Not available 1 (washer) (only available in KIT3)
16l N/A Not available 1 (extension spring) (only available in KIT3)
16m 272-3948 Left hand thumb nut 1
16n N/A Not available 2 (bushing) (only available in KIT3)
16o N/A Not available 1 (bushing) (only available in KIT3)
16p 372-2928 Side broom guard 1
16q N/A Not available 1 (left hand motor braket weldment) (only available in KIT3)
16r N/A Not available 1 (left hand squeegee blade arm assembly) (only available in KIT3)
16s 472-8233 SIDE BROOM MOTOR KIT 1
16t N/A Not available 1 (swueegee blade lift bracket) (only available in KIT3)
16u N/A Not available 1 (cable assembly) (only available in KIT3)
16v 372-2931 Left hand squeegee blade hub assembly 1
16w 372-2929 Side broom 1
17 372-2932 Actuator bracket weldment 1
N/S 372-2933 Motor brush kit 1 (for 15t and 16s)
KIT1 372-2934 Broom bearing kit 1 (includes 3-4, 6, 12,
KIT2 372-2935 Right hand broom bracket kit 1 (includes 15b-15g, 15i, 15k, 15n-15o, 15r-15s, 15u-15v)
KIT3 372-2936 Left hand broom bracket kit 1 (includes 16b-16g, 16i, 16k-16l, 16n-16o, 16q-16r, 16t-16u)
KIT4 372-2937 Broom system hardware kit 1 (includes 1-2, 5, 7-11)
KIT5 372-2938 Broom assembly hardware kit 1 (includes 15f-15h, 15j, 16f-16h, 16j)

Broom Arm Assembly - 372-0075
RefNbr Part Number Description Req Notes
1 172-4521 Spring com .75 x 1.68 1
2 N/A Not available 1 (nut)
3 N/A Not available 1 (nut)
4 N/A Not available 1 (screw)
5 999-0114 Washer 1/2 SAE flat 2
6 999-1531 Screw 3/8-16 x 1 hex washer head zinc plated 1
7 999-0628 Nut 3/8-16 hex jam stainless steel 1
8 999-0181 Nut 1/4-20 hex jam plain finish 1
9 N/A Not available 2 (ring)
10 999-9094 Screw 3/8-16 x 3 hex head stainless steel 1
11 N/A Not available 2 (screw)
12 N/A Not available 3 (washer)
13 N/A Not available 2 (bearing)
14 N/A Not available 1 (bushing)
15 N/A Not available 1 (bushing)
16 N/A Not available 1 (upper arm assembly)
17 N/A Not available 1 (lower arm assembly)
18 N/A Not available 1 (hinge weldment)
19 N/A Not available 1 (hinge weldment)

Solution System Assembly 1 - 372-0076
RefNbr Part Number Description Req Notes
1 N/A Not available 1 (filter) (only avaialble in KIT1)
2 N/A Not available 1 (barb) (only available in KIT2)
3 999-1862 Washer #10 flat SAE stainless steel 8 (included in KIT1 and KIT4)
4 999-0333 Screw 10-24 x 1/2 pan head phillips stainless steel 4 (included in KIT4)
5 999-0830 Screw 1/4-20 x 1 hex head plain finish 1 (included in KIT4)
6 999-0123 Washer 1/4 SAE flat zinc plated 9 (included in KIT4)
7 N/A Not available 2 (screw) (only available in KIT4)
8 999-0342 Screw 1/4-20 x 1 pan head phillips stainless steel 1
9 999-0199 Nut 10-24 nylon insert lock zinc plated 4 (included in KIT1)
10 999-1532 Screw 1/4-20 x 1/2 hex head stainless steel 2 (included in KIT1)
11 999-1032 Screw 1/4-20 x 5/8 hex head stainless steel 5 (included in KIT4)
13 181-0421 Spacer 1
14 272-3968 U-bolt 2
15 N/A Not available 4 (clamp) (only available in KIT1 and KIT2)
16 N/A Not available 1 (pipe cap) (only available in KIT2)
17 472-6384 BARB ELBOW MALE 90 E00037 1 (included in KIT1)
18 N/A Not available 2 (hose) (only available in KIT1 and KIT2)
19 N/A Not available 1 (washer) (only available in KIT2)
20 N/A Not available 1 (solution valve) (only available in KIT1)
21 372-2939 Solution tank 1
22a N/A Not available 1 (seat assembly) (includes 22b-22i)
22b 999-0024 Washer 5/16 flat stainless steel 4
22c 999-1099 Bolt 1/4-20 x 3/4 hex head stainless steel 3
22d 999-0024 Washer 5/16 flat stainless steel 3
22e 999-0211 Nut 5/16-18 hex nylon insert lock zinc plated 4
22f 372-2940 Seat mount weldment 1
22g 272-7645 Seat (OBSOLETE) 1
22h 170-8321 Seat adjuster kit 1
22i 272-9417 Seat switch 1
23 372-2941 Pressure sensing tube assembly 1
24 272-9352 Raw cap with tether 1
25 N/A Not available 1 (valve shield) (only available in KIT1)
26 372-2942 Plate seal 1
27 372-2943 Plate spacer 1
28 372-2944 Plate (OBSOLETE) 1
29 372-1408 Nut plate 1
30 372-2945 Bulb seal 1
31 372-2946 Cover weldment (OBSOLETE) 1
32 372-2947 Cover hanger weldment (OBSOLETE) 1
33 372-2948 Tygon tube 1
34 272-8795 Seat rod 1
35 172-0261 Barb adapter 2 (included in KIT1)
KIT1 372-2949 Solution filter kit 1 (includes 1, 3, 9-10, 15, 17-18, 20, 25, 35)
KIT2 372-2950 Solution drain hose kit 1 (includes 2, 15-16, 18-19)
KIT4 372-2951 Solution system hardware kit 1 (includes 3-7, 11-12)

Solution System Assembly 2 - 372-0077
RefNbr Part Number Description Req Notes
1 999-1260 Screw 1/4-20 x 1 1/2 hex cap stainless steel 1 (included in KIT3)
2 999-1032 Screw 1/4-20 x 5/8 hex head stainless steel 1 (included in KIT3)
3 999-1532 Screw 1/4-20 x 1/2 hex head stainless steel 2 (included in KIT4)
4 999-9004 Washer 5/16 SAE flat stainless steel 5 (included in KIT3 and KIT4)
5 999-1862 Washer #10 flat SAE stainless steel 12 (included in KIT4)
6 999-0333 Screw 10-24 x 1/2 pan head phillips stainless steel 12 (included in KIT4)
7 999-0123 Washer 1/4 SAE flat zinc plated 2 (included in KIT4)
8 999-1232 Screw 5/16-18 x 3/4 hex head stainless steel 8 (included in KIT3 and KIT4)
9 999-0294 Nut 1/4-20 hex nylon lock type NE stainless steel 2 (included in KIT3)
10 N/A Not available 3 (washer) (only available in KIT4)
11 272-7623 Right side latch 1 (included in KIT3)
12 272-9915 Pipe plug 2
13 N/A Not available 1 (latch mount bracket) (only available in KIT3)
14 N/A Not available 1 (recovery latch handle) (only available in KIT3)
15 372-2952 Tether hook 1
16 372-2953 Contactor panel cover 1
17 372-2954 Cover panel 1
18 372-2955 Fuse cover panel 1
19 372-2956 Plate gasket 1
KIT3 372-2957 Recovery tank latch kit 1 (includes 1-4, 8-9, 11, 13-14)
KIT4 372-2951 Solution system hardware kit 1 (includes 3-8, 10)

Squeegee System Assembly - 372-0078
RefNbr Part Number Description Req Notes
1 N/A Not available 2 (nut) (only available in KIT1)
2 999-9128 Washer 3/8 SAE flat stainless steel 4 (included in KIT1)
3 999-0114 Washer 1/2 SAE flat 2 (included in KIT2)
4 N/A Not available 1 (clevis pin) (only available in KIT2)
5 N/A Not available 1 (clevis pin) (only available in KIT2)
6 N/A Not available 2 (bow tie cotter pin) (only available in KIT2)
7 N/A Not available 2 (flange bearing) (only available in KIT1)
8 372-2958 Squeegee tool assembly 1 (includes red gum rubber blades)
9a N/A Not available 1 (squeegee support assembly) (includes 9b-9l)
9b N/A Not available 2 (washer) (only available in KIT3)
9c 999-0630 Washer 3/4 SAE flat 1 (included in KIT5)
9d N/A Not available 2 (nut) (only available in KIT3)
9e N/A Not available 1 (screw) (only available in KIT5)
9f N/A Not available 2 (nut) (only available in KIT4)
9g 999-1895 Screw 1/4-20 x 7/8 flat head phillips stainless steel 2 (included in KIT4)
9h N/A Not available 1 (rod end) (only available in KIT5)
9i N/A Not available 2 (squeegee caster) (only available in KIT3)
9j N/A Not available 1 (squeegee lift pad) (only available in KIT4)
9k 372-2959 Support weldment 1
9l 372-2960 Adjustment handle 1
10 372-2961 Squeegee lift arm 1
11 372-2962 Extension spring 2
12 372-2963 Squeegee lift actuator 1
13 N/A Not available 1 (spacer) (only available in KIT2)
14 N/A Not available 2 (screw) (only available in KIT1)
KIT1 372-2964 Squeegee lift hardware kit 1 (includes 1-2, 7, 14)
KIT2 372-2965 Squeegee actuator hardware kit 1 (includes 3-6, 13)
KIT3 372-2966 Squeegee caster kit 1 (includes 9b, 9d, 9i)
KIT4 372-2967 Squeegee lift pad kit 1 (includes 9f-9g, 9j)
KIT5 372-2968 Squeegee rod end kit 1 (includes 9c, 9e, 9h)

Squeegee Assembly - 372-0079
RefNbr Part Number Description Req Notes
0 372-2958 Squeegee tool assembly 1 (includes 1-17)
1 999-0336 Screw 6-32 x 3/8 pan head phillips stainless steel 2 (included in KIT2)
2 999-0114 Washer 1/2 SAE flat 2 (included in KIT3)
3 999-1032 Screw 1/4-20 x 5/8 hex head stainless steel 1 (included in KIT4)
4 N/A Not available 2 (nut) (only available in KIT2)
5 N/A Not available 2 (bow tie cotter pin) (only available in KIT3)
6 N/A Not available 2 (screw) (only available in KIT4)
7 272-4838 Squeegee knob 2
8 172-2085 Wheel 2 (included in KIT3)
9 N/A Not available 1 (latch assembly) (only available in KIT2)
10 N/A Not available 4 (squeegee clip) (only available in KIT1)
11 372-2969 Push pull clamp 1
12 N/A Not available 1 (squeegee weldment) (order 372-2958 if you need to replace)
13 372-1145 Squeegee blade kit gum rubber (red) 1 (all squeegee blade kits include both front and rear squeegee blades)
14 372-2970 Squeegee strap 1
15 372-2971 Weldment strap 1
16 372-2972 Stud 3/8-16 x 1 3/4 2
17 372-2973 Adjustment plate 1
N/S 372-1145 Squeegee blade kit gum rubber (red) 1 (all squeegee blade kits include both front and rear squeegee blades)
N/S 572-1606 BLADE KIT-SQGEE-GUM 1 (all squeegee blade kits include both front and rear squeegee blades) (optional)
N/S 572-1607 BLADE KIT-SQGEE-PU 1 (all squeegee blade kits include both front and rear squeegee blades) (optional)
KIT1 372-2974 Squeegee clip kit 1 (includes 10)
KIT2 372-2975 Squeegee latch kit 1 (includes 1, 4, 9)
KIT3 372-2976 Squeegee wheel kit 1 (includes 2, 5, 8)
KIT4 372-2977 Squeegee tool hardware kit 1 (includes 3 and 6)

Wheel System Assembly - 372-0080
RefNbr Part Number Description Req Notes
1 372-2978 Lug nut kit 1
2 999-0114 Washer 1/2 SAE flat 8 (included in KIT2)
3 999-9004 Washer 5/16 SAE flat stainless steel 8 (included in KIT1)
4 N/A Not available 2 (nut) (only available in KIT1)
5 999-0977 Screw 5/16-18 x 3 1/2 hex head stainless steel 2 (included in KIT1)
6 N/A Not available 6 (screw) (only available in KIT1)
7 N/A Not available 6 (screw) (only available in KIT2)
8 N/A Not available 8 (screw) (only available in KIT2)
9 372-2979 Drive wheel 1
10 N/A Not available 1 (traction motor) (only available in KIT1)
11 372-2980 Traction drive gearbox (OBSOLETE) 1
12 272-3779 Mold-on wheel 16.2 x 4 2
13 372-2981 Brake and spindle assembly 2
14 N/A Not available 1 (splash shield) (only avaialble in KIT1)
15 N/A Not available 2 (cotter pin) (only available in KIT2)
16 N/A Not available 1 (nut) (only available in KIT2)
17 N/A Not available 2 (spacer washer) (only available in KIT2)
18 272-3783 Grease cap 2
N/S 372-2982 Speed sensor 1 (for 9)
N/S 372-2983 Thermal sensor 1 (for 9)
N/S 272-3780 Wheel bearing 1 (for 12)
N/S 272-3781 Snap ring 1 (for 12)
N/S 272-3777 Brake shoe kit 1 (for 13)
KIT1 372-2984 Drive motor kit 1 (includes 3-6, 10, 14)
KIT2 372-2985 Wheel system hardware kit 1 (includes 2, 7-8, 15-17)
KIT3 372-2986 Ring/pinion gear kit 1 (for 11)

Ladder Diagram 1 - 372-0081
RefNbr Part Number Description Req Notes
A1 372-1482 Control board kit 1
A3 372-2723 User interface panel assembly (OBSOLETE) 1
A4 N/A Not available (engine system)
BATT 162-0042 12V 115Ah AGM battery (Group 31) 3
BAT2 162-0057 12V 150Ah wet battery 1
CB1 272-7727 20amp circuit breaker 1
CB2 272-6708 25amp circuit breaker 1
CB3 272-6708 25amp circuit breaker 1
CB4 991-1628 5amp circuit breaker 1
CB6 272-9755 15amp circuit breaker 1
CB9 272-9755 15amp circuit breaker 1
CB12 272-9755 15amp circuit breaker 1
F1 472-5774 FUSE 400 AMP 1
G1 372-1552 Alternator 1
H1 172-9146 Back-Up alarm 1
H2 172-9432 36V horn 1
K9 172-2805 36V contactor 1
K10 172-2805 36V contactor 1
K14 172-1779 36V relay SPST 1
K15 172-1779 36V relay SPST 1
L2 272-2586 36V solenoid valve 1
LT1 372-2987 Trouble lamp (OBSOLETE) 1
M17 272-7679 12V detergent pump 1
M18 272-7679 12V detergent pump 1
M19 272-5716 Solution control pump 1
M22 372-2988 Pump adapter cable kit 1
M23 372-2989 Pump adapter cable kit 1
M25 272-5716 Solution control pump 1

Ladder Diagram 2 - 372-0082
RefNbr Part Number Description Req Notes
A1 372-1482 Control board kit 1
B1 372-1515 Current sensor 1
B2 372-1515 Current sensor 1
B3 372-1515 Current sensor 1
K1 172-2805 36V contactor 1
K2 172-2805 36V contactor 1
K3 172-2805 36V contactor 1
K4 172-2805 36V contactor 1
K5 172-2805 36V contactor 1
K6 172-2805 36V contactor 1
K8 172-2805 36V contactor 1
K11 272-1322 Motor contactor 1
K12 272-1322 Motor contactor 1
L1 272-2193 Solenoid valve assembly 1
LT2 372-2319 Head light assembly 1
LT3 372-2319 Head light assembly 1
LT4 372-2990 Turn signal light 1
LT5 372-2991 12V tail light 1
LT6 372-2991 12V tail light 1
LT7 372-2990 Turn signal light 1
LT8 372-2992 Curb light 1
LT9 372-2993 12V red light 1
LT10 472-6242 BEACON WARNING 1
LT11 372-2993 12V red light 1
M11 372-2892 Scrub deck actuator 1
M12 372-2963 Squeegee lift actuator 1
M13 272-7198 36V actuator 1
M14 372-1467 Shaker motor kit 1
M21 372-2994 Broom lift actuator 1
M26 372-2819 Dump door actuator 1
R4 N/A Not available 1 (part of M21)
S1 272-8850 Proximity sensor 1

Ladder Diagram 3 - 372-0083
RefNbr Part Number Description Req Notes
A2 372-1508 Traction controller kit 1
CB5 272-9374 10amp circuit breaker 1
CB7 272-6708 25amp circuit breaker 1
CB8 272-6708 25amp circuit breaker 1
F2 172-8836 150amp fuse 1
K1 172-2805 36V contactor 1
K2 172-2805 36V contactor 1
K3 172-2805 36V contactor 1
K4 172-2805 36V contactor 1
K5 172-2805 36V contactor 1
K6 172-2805 36V contactor 1
K7 472-5722 CONTACTOR 36V TYPE 4 1
K8 172-2805 36V contactor 1
K11 272-1322 Motor contactor 1
K12 272-1322 Motor contactor 1
M1 472-8051 MOTOR-36 VDC-3000 RPM-1.1 HP 1
M2 372-2907 Scrub motor assembly (OBSOLETE) 1
M3 372-2907 Scrub motor assembly (OBSOLETE) 1
M4 372-2908 Scrub motor assembly 1
M5 372-2997 Impeller assembly 1
M6 372-2874 36V vacuum motor 1
M7 372-2874 36V vacuum motor 1
M8 472-8233 SIDE BROOM MOTOR KIT 1
M9 472-8233 SIDE BROOM MOTOR KIT 1
M10 372-2833 36V motor 1
M24 372-2998 Traction motor 1
R1 N/A Not available 1 (part of 272-880)
N/S 372-2854 Brush motor kit 1 (for M1)
N/S 572-4029 Brush motor kit 1 (for M2)
N/S 572-4029 Brush motor kit 1 (for M3)
N/S 572-4029 Brush motor kit 1 (for M4)
N/S 372-2933 Motor brush kit 1 (for M8 and M9)

Ladder Diagram 4 - 372-0084
RefNbr Part Number Description Req Notes
A5 372-1439 Steering controller 1
CB10 272-6708 25amp circuit breaker 1
E4 372-1443 Torque feedback device (OBSOLETE) 1
K10 172-2805 36V contactor 1
K14 172-1779 36V relay SPST 1
M16 472-7286 MOTOR STEERING 36V 1
R3 N/A Not available 1 (resistor)
S16 272-8850 Proximity sensor 1
S17 272-8850 Proximity sensor 1

Kubota Diesel Engine Ladder Diagram - 372-0085
RefNbr Part Number Description Req Notes
B4 N/A Not available 1 (magnetic pick up) (part of Apecs 3000 Governor)
CB11 372-1502 40amp circuit breaker (OBSOLETE) 1
DV6 272-7812 Starter motor 1
E1 N/A Not available 1 (glow plug)
E2 N/A Not available 1 (glow plug)
E3 N/A Not available 1 (glow plug)
G2 372-2792 Alternator 1
K13 272-7725 12V 75amp relay 1
M15 N/A Not available 1 (actuator) (part of the Apecs 3000 Governor)
M20 272-7818 Electronic fuel pump 1
S18 272-7814 Temperature switch 1
S19 272-7813 Oil pressure switch 1
N/S 372-2763 Controller governor 1

Kubota LPG Engine Ladder Diagram - 372-0086
RefNbr Part Number Description Req Notes
372-2788 Alternator with pulley 1
372-2787 LP lock off with filter 1
472-9176 SWITCH ENGINE OIL PRESSURE 1
272-7814 Temperature switch 1
372-2158 Starter motor 1
Webpage Problem Reporting